Minuteman EX-12 Parts And Instruction Manual
W/ optional hose and wand package
Hide thumbs
Also See for EX-12:
- Parts and instruction manual (10 pages) ,
- Parts and instruction manual (18 pages)
Related Manuals for Minuteman EX-12
Summary of Contents for Minuteman EX-12
- Page 1 Parts and Instruction Manual EX12 Carpet Extractor W/ Optional Hose and Wand Package...
- Page 2 This manual is furnished with each new MINUTEMAN EX 12 . This provides the necessary operating and preventive maintenance instructions. Operators must read and understand this manual before operat- ing or servicing this machine. This machine was designed to give you excellent performance and efficiency. For best results and minimal cost, please follow the general guidelines below: ·...
-
Page 3: Table Of Contents
Draining Recovery Tank ....................4 Machine Maintenance ....................4 Weekly Maintenance ....................4 Storing Machine ......................5 Troubleshooting ......................5 Parts List ........................7 EX12 .......................... 7 EX12-H ........................9 Minuteman International Made Simple Commercial Limited Warranty ....11 Parts and Instruction Manual... -
Page 4: Safety Precautions
SAFETY PRECAUTIONS Safety Precautions 4. Before leaving or servicing machine: -Turn off machine. -Unplug cord from wall outlet. This machine is intended for commercial use. It is 5. When servicing machine: designed to clean carpet and upholstery in an indoor -Unplug cord from wall outlet. -
Page 5: Safety Labels
Safety Labels The safety labels appear on the machine in various locations. Replace labels if they become damaged or cannot be read. WARNING: Flammable materials can cause an explosion or fire. Do not use flammable materials in tank(s). Flammable materials or reactive metals can cause explosion or fire. -
Page 6: Machine Set Up
Machine Set Up MACHINE SET UP Pre-Operation PRE-OPERATION Vacuum carpet and remove other debris. Perform MACHINE SETUP procedures. Inspect power cord for damage. 7. Connect solution hose and make sure it is firmly SETUP Set Up secured. Carefully check carton for signs of damage. 8. -
Page 7: Operation
Operation Machine Maintenance To keep machine in good working condition, simply follow machine’s daily and weekly maintenance WARNING: Flammable materials or procedures. reactive metals can cause an explosion or fire. Do not pick up. FOR SAFETY: When servicing machine, unplug cord from wall outlet. -
Page 8: Storing Machine
Storing Machine Before storing machine, be certain to completely drain and rinse tanks of all water and solution. Drain and dry the vacuum hose as well, using the drain hose provided Store machine in a dry area in the upright position. Open recovery tank cover to promote air circulation ATTENTION: Do not expose to rain. - Page 9 SYMPTOM: HEATER IS NOT WORKING PROPERLY: PROBLEM: The back up sensor, mounted on the heater has popped. SOLUTION: Reset sensor by pushing in button. PROBLEM: Heating element is bad. SOLUTION: Replace element. SYMPTOM: VACUUM MOTOR IS NOT WORKING PROPERLY: PROBLEM: Hose not connected tightly to upholstery tool or machine.
-
Page 10: Parts List
Parts List EX12 EX12 PARTS LIST Qty Per Unit Minuteman Part Number Description 15' vacuum and solution hose 121000 EACH assembly 121001 EACH EZ Glider wand 12" single bend 121002 EACH elbow, inlet assy 1-1/2" 121003 EACH qd, brass, 1/4" m... - Page 11 EX12 Continued 121068 EACH bracket, front hinge, sp/fb 121070 EACH vac support, 2 stage, 3-1/8" 121071 EACH bracket, L, sp/fb 121073 EACH caster, 5" 121075 EACH bracket, rear, fb/spy 121076 EACH knob, thumb screw, for bracket 121078 EACH elbow, U, 180, 1-1/2", float...
-
Page 12: Ex12-H
Parts List EX12-H Qty Per Minuteman Part Number Unit Description 15' vacuum and solution hose 121000 EACH assembly 121001 EACH EZ Glider wand 12" single bend 121002 EACH elbow, inlet assy 1-1/2" 121003 EACH qd, brass, 1/4" m 121004 EACH qd, brass, 1/4"... - Page 13 EX12-H Continued 121048 EACH insulation, sm. heater, wrap 121049 EACH insulation, sm heater, end cap 121050 EACH manifold, single vac, w/gasket 121051 EACH clamp, hose, 2-1/4 DIA 121052 EACH cap, axle, 1/2" 121053 EACH fitting, strain relief, cord 121054 EACH valve, drain, 1-1/2"...
-
Page 14: Minuteman International Made Simple Commercial Limited Warranty
A potential health hazard exits without original equipment replacement. All warranted items become the sole property of Minuteman or its original manufacturer, whichever the case may be. Minuteman disclaims any implied warranty, including the warranty of merchantability and the warranty of fitness for a particular purpose.