When your package is delivered, check the carton carefully for signs LOWING WARNINGS AND INSTRUCTIONS of rough handling. If your R100C is damaged, notify the WILL VOID THE WARRANTY. carrier immediately and request an inspection. Be sure to keep the carton, packing inserts, packing lists and carri- WARNING! er’s receipt until the inspector has verified your claim.
GROUNDING INSTRUCTIONS FOR • All repairs must be done by an authorized MINUTEMAN repair station. 115VOLT: • Do not use replacement parts other than original MINUTEMAN parts. This piece of equipment must be grounded. Should an • Do not allow your spray stream to remain in one electrical malfunction occur, grounding provides a path fixed location as surface damage may occur.
• Adhere to the appropriate mix ratios for all chemicals corners. Do not run this R100C over cord. Keep cord • For optimal performance, it is suggested that the away from heated surfaces.
1. Handle- Used to maneuver and position the R100C. 6. Solution line Q.D.- Pressurized connection for solu- Contains switch box (For switchbox, see #10) tion line 2. Recovery tank and lid- Tank collects recovered waste 7. Twist lock pigtail- connects to 50ft power cord water.
CLEANING CARPET CLEANING UPHOLSTERY: 1. Using a dedicated dry vacuum, pre-vacuum the space Cleaning upholstery with success requires a good knowl- to be cleaned to remove as much dirt as possible. Do edge of the type of fabric to be worked on. Look for the not use the extractor to dry vacuum as it does not cleaning instruction label sewn on the underside of the have a dry filter.
ELECTRICAL SYSTEM PROBLEM SOLUTION NO ELECTRICAL POWER 1. Defective power cord. 2. House or building circuit breaker tripped POWER IS INTERMITTENT TO ONE OR ALL MO- 1. Faulty electrical cable. TORS 2. Defective switches. 3. Loose terminal or discolored terminal connections. VACUUM SYSTEM PROBLEM SOLUTION...
Page 11
C 11244 Washer, .56 X 1.5 X .05 AOOl 24 Hex Nut, .25 NPT Brass D00373 Inlet Filter, .25 NPT C 11143 Screw, 1-4 20 X 1.5 in, SS Pan Head, Phillips Sl 1179 Non-Skid Tape, 1 in. Roll H13699 MINUTEMAN LABEL F11791-MM SOLUTION TANK LID...
Page 13
R100C BASE 4-21-16 ITEM PART NUMBER DESCRIPTION QTY. C00297 Screw,#8 X .25 in, Pan Head J11863 Hose, 3 in J00639 Screw Clamp, 1.63 - 2.43in. J00618 Vacuum Hose, 2in Grey, Wire, 22 in lg F11178-BLK Intercooler, , Black C00273 Locknut, 1-4 X 20, Nylon, SS C00233 Washer, Flat, .25 in...
Page 18
“Excellence Meets Clean” Minuteman International · 14N845 U.S. Route 20 · Pingree Grove, Illinois 60140 USA Phone 630- 627-6900 · Fax 630- 627-1130 E-Mail: tech@minutemanintl.com Website www.minutemanintl.com A Member of the Hako Group...