Part 4 Troubleshooting Inverter K Series - Daikin VRV K Manual

SI-95.BOOK Page 73 Friday, March 31, 2000 10:59 AM
Si-95
1. Diagnosis by Malfunction Code.............................................................75
2. Troubleshooting ....................................................................................77
Troubleshooting Inverter K Series
Troubleshooting
Inverter K Series
1.1 Diagnosis by Malfunction Code ............................................................. 75
1.2 Failure Diagnosis................................................................................... 76
2.1 Indoor Unit: Error of External Protection Device.................................... 77
2.2 Indoor Unit: PC Board Defect ................................................................ 78
2.3 Indoor Unit: Malfunction of Drain Level Control System (33H).............. 79
2.4 Indoor Unit: Fan Motor (M1F) Lock, Overload....................................... 80
2.5 Indoor Unit: Malfunction of Swing Flap Motor (M1S)............................. 81
2.6 Indoor Unit: Malfunction of Moving Part of
Electronic Expansion Valve (Y1E)......................................................... 82
2.7 Indoor Unit: Drain Level above Limit ..................................................... 83
2.8 Indoor Unit: Malfunction of Capacity Determination Device .................. 84
2.9 Indoor Unit: Malfunction of Thermistor (R2T) for Liquid Pipe ................ 85
2.10 Indoor Unit: Malfunction of Thermistor (R3T) for Gas Pipes ................. 86
2.11 Indoor Unit: Malfunction of Thermistor (R1T) for Air Inlet...................... 87
2.12 Indoor Unit: Malfunction of Thermostat Sensor in Remote Controller ... 88
2.13 Outdoor Unit: Actuation of Safety Device .............................................. 89
2.14 Outdoor Unit: PC Board Defect ............................................................. 90
2.15 Outdoor Unit: Actuation of High Pressure Switch.................................. 91
2.16 Outdoor Unit: Actuation of Low Pressure Sensor.................................. 92
2.17 Outdoor Unit: Malfunction of Moving Part of
Electronic Expansion Valve (Y1E)......................................................... 93
2.18 Outdoor Unit: Abnormal Discharge Pipe Temperature.......................... 94
2.19 Outdoor Unit: Malfunction of Thermistor for Outdoor Air (R1T)............. 95
2.20 Outdoor Unit: Malfunction of Discharge Pipe Thermistor (R3T) ............ 96
2.21 Outdoor Unit: Malfunction of Thermistor (R4T) for Suction Pipe ........... 97
2.22 Outdoor Unit: Malfunction of Thermistor (R2T) for Heat Exchanger ..... 98
2.23 Outdoor Unit: Malfunction of Discharge Pipe Pressure Sensor............. 99
2.24 Outdoor Unit: Malfunction of Suction Pipe Pressure Sensor............... 100
2.25 Outdoor Unit: Malfunction of Oil Temperature Thermistor (R5T) ........ 101
2.26 Low Pressure Drop Due to Refrigerant Shortage or
Electronic Expansion Valve Failure ..................................................... 102
2.27 Negative Phase, Open Phase ............................................................. 103
2.28 Malfunction of Transmission Between Indoor Units ............................ 104
2.29 Malfunction of Transmission Between Remote Controller
and Indoor Unit .................................................................................... 105
2.30 Malfunction of Transmission Between Outdoor Units.......................... 106
2.31 Malfunction of Transmission Between MAIN
and SUB Remote Controllers .............................................................. 107
2.32 Malfunction of Transmission Between Indoor
and Outdoor Units in the Same System .............................................. 108
2.33 Excessive Number of Indoor Units ...................................................... 109
Part 4
73