Genie Z-45/22 Service Manual page 10

800-610-4101
ActionRental.com
TABLE OF CONTENTS
Section Five
x
Troubleshooting Flow Charts
Introduction ............................................................................................................... 5 - 1
1 Engine Will Not Crank Over ............................................................................ 5 - 3
2 Engine Cranks Over But Will Not Start - Gasoline/LPG Models ..................... 5 - 5
3 Engine Cranks Over But Will Not Start - Deutz Diesel Models ..................... 5 - 12
4 Engine Will Not Start On LPG, But Will Start On Gasoline
- Gasoline/LPG Models ................................................................................. 5 - 15
5 Engine Will Not Start On Gasoline, But Will Start On LPG
- Gasoline/LPG Models ................................................................................. 5 - 17
6 Engine High Idle Inoperative - Gasoline/LPG Models ................................... 5 - 19
7 Engine Low Idle Inoperative - Gasoline/LPG Models .................................... 5 - 22
8 Engine High Idle Inoperative - Deutz Diesel Models ..................................... 5 - 23
9 Engine Low Idle Inoperative - Deutz Diesel Models ...................................... 5 - 25
10 All Functions Inoperative, Engine Starts and Runs ....................................... 5 - 26
11 All Lift and Steer Functions Inoperative, Drive Functions Operational .......... 5 - 27
12 Ground Controls Inoperative, Platform Controls Operate Normally .............. 5 - 28
13 Platform Controls Inoperative, Ground Controls Operate Normally .............. 5 - 29
14 Secondary Boom Up Function Inoperative ................................................... 5 - 30
15 Secondary Boom Down Function Inoperative ............................................... 5 - 32
16 Primary Boom Up Function Inoperative ........................................................ 5 - 34
17 Primary Boom Down Function Inoperative ................................................... 5 - 36
18 Primary Boom Extend Function Inoperative ................................................. 5 - 38
19 Primary Boom Retract Function Inoperative ................................................. 5 - 40
20 Turntable Rotate Function Inoperative .......................................................... 5 - 41
21 Turntable Rotate Left Function Inoperative ................................................... 5 - 43
22 Turntable Rotate Right Function Inoperative ................................................ 5 - 44
23 All Platform Leveling Functions Inoperative .................................................. 5 - 45
24 Platform Level Up Function Inoperative ........................................................ 5 - 46
25 Platform Level Down Function Inoperative ................................................... 5 - 47
Genie Z-45/22
Service Manual - Second Edition
Part No. 32960