Related Manuals for Champion 30000
Summary of Contents for Champion 30000
-
Page 1: Air Compressor
30000 Rev 30000-20080208 10006 Santa Fe Springs Road Santa Fe Springs, CA 90670 USA Made in China Owner’s Manual and Operating Instructions 2 Gallon AIR COMPRESSOR... -
Page 3: Table Of Contents
Table of Contents Introduction ........1 Troubleshooting ......11 This Booklet ..........1 Warranty ........13 Manual Conventions ......2 Warranty Qualifications ......13 Safety Rules ........3 Repair/Replacement Warranty ....13 Controls and Features ....... -
Page 5: Introduction
Every effort has been made to ensure the Congratulations on your purchase of a accuracy and completeness of the Champion Power Equipment Air information in this manual. We reserve the Compressor. With proper use and right to change, alter and/or improve the... -
Page 6: Manual Conventions
NOTE If you have questions regarding your air WARNING compressor, we can help. Please call our help line at 1-877-338-0999. WARNING indicates a potentially hazardous could situation which, if not avoided, result in death or serious injury. Rev 30000-20080208... -
Page 7: Safety Rules
Never remove or attempt to adjust the after use. pressure switch, safety valve or other components that control tank pressure. Rev 30000-20080208... - Page 8 Use additional air hose to reach High speed release of air and liquid may stir high locations. up rust and debris and may result in injury. Rev 30000-20080208...
-
Page 9: Controls And Features
(2) Outlet pressure regulator knob – Adjust to regulate pressure output for (5) Motor Switch/Tank Regulator particular accessory or air tool housing – Control center tank pressure/On-Off switch (3) Tank pressure gauge – Displays tank pressure Rev 30000-20080208... -
Page 10: Operation
7. Wipe down and store in a clean, dry, and hoses, accessories, are all in working non-freezing location order. 7. Plug power cord directly into a properly grounded power source of the correct voltage Rev 30000-20080208... -
Page 11: Maintenance
Make sure to consistently drain moisture 5. Replace safety relief valve if plunger is from tank before and after each use. not functioning properly. NOTE For service or parts assistance, contact our toll- free help line at 1-877-338-0999. Rev 30000-20080208... -
Page 12: Specifications
Specifications Specifications 2 gallon Tank Portable Inflator/Compressor Volt 120V/60Hz Air Displacement 0.7 SCFM@40psi 0.5 SCFM@90psi Max Pressure 100 PSI Power ½ HP max ¼ HP running Motor Speed 3000 RPM Tank Size 2 gallon Rated Electricity 2 Amps Rev 30000-20080208... -
Page 13: Parts Diagram
Specifications Parts Diagram Rev 30000-20080208... -
Page 14: Parts List
DRAIN VALVE 30000-41 REGULATOR ASSEMBLY 30000-42 SAFETY VALVE 30000-43 TANK PRESSURE GAUGE 30000-44 OUTLET PRESSURE GAUGE 30000-45 QUICK COUPLER 30000-46 RUBBER FOOT 30000-47 WASHER 30000-48 SCREW 30000-49 HEX NUT 30000-50 CORD CONNECTOR 30000-51 LONG TAPPING SCREW 30000-52 ADAPTOR COUPLER Rev 30000-20080208... -
Page 15: Troubleshooting
Tank pressure is greater than auto Open tank drain valve to release tank motor “kick in” pressure Defective motor, motor switch Call Champion Hotline # Overheating Insufficient Ventilation Place compressor in environment with well circulated supply of cool, dry air. - Page 16 Malfunctioning pilot valve Clean or replace Moisture in discharge air Excessive condensation in air tank due Always drain tank after use. Drain to atmospheric humidity more often in areas of high humidity. Use air line filter Rev 30000-20080208...
-
Page 17: Warranty
Warranty Qualifications Pump or valve failure due to rain, excessive humidity, corrosive environments or other Champion Power Equipment (CPE) will register contaminants; rusted tanks including but not this warranty upon receipt of your Warranty limited to rust due to improper drainage or Registration Card and a copy of your sales receipt corrosive environments. -
Page 18: Notes
Notes Notes Rev 30000-20080208...