Important Safety Instructions - Hayward SP2305X7 Owner's Manual

1. I MPORTA ANT SAFE
WAR NING – Read
Failure to f follow instruct
WARN NING
– Sucti
S Suction in sucti on outlets and/
i njury and/or de eath due to the
Hair Entra pment
- Hair ca
Limb Entra apment - A limb
cracked, m issing, or not s
Body Suct tion Entrapme
Eviscerati on/ Disembow
sump or su uction outlet cov
disembowe elment.
Mechanic al Entrapmen
opening of a suction outle
WARN NING - To Red
o When outlets are W
be e installed. Suc
ap part, as measur
o D ual suction fitti
o D ual suction fitti
o Th he maximum sy
o N ever use Pool o
o Re eplace damage
o In n addition two o
gu uidelines, follow
o In nstallation of a v
WARN NING –
Failure
suction ou utlets can resu
WARN NING –
Failure
material ca an result in an
WARN NING –
Suctio
replaced a at least every s
CAUT TION –
Compo
being used d as means of
on this pro duct. Closely s
positioned to prevent chil
WARN NING – Hazard
start up, no ormal operation
follow safe ty and operatio
and clamp due to pressure
pool and sp pa water circula
be in open position. Befo
back to the e pool. Do not c
open filter manual air relie
is discharg ed.
WARN NING – Separ
pump and/ /or filter compo
servicing p ool and spa cir
circulation system if a sys
circulation system unless
circulation n system at mo
air can cau se components
high volum me blower when
ETY INST TRUCTION
, understand , and follow
ions can cause e severe injury
on Entrapme ent Hazard.
/or suction outl let covers whic
following entra apment hazards
an become enta angled in suctio
b inserted into an opening of a
ecurely attache ed can result in
ent - A negative pressure appli
welment
- A ne egative pressur
ver which is, da amaged, broken
t - There is pote ential for jewelry
et cover resultin ng in mechanica
uce the risk o of Entrapmen nt Hazards:
e small enough to be blocked
ction outlets in the same plan
red from near p point to near po
ngs shall be pl aced in such lo ocations and dis
ngs shall not b e located on se
ystem flow rate shall not excee
or Spa if any suc ction outlet com
ed, broken, crac cked, missing, o
or more suction outlets per pum
w all National, State, and Loca
vacuum release e or vent system
e to remove pr ressure test plu
lt in an increas se potential fo or suction entra
e to keep suct ion outlet com mponents clear
increase pote ential for suctio
on outlet comp ponents have a
even years or if found to be
onents such as s the filtration
access to the pool by young
upervise childr ren at all times.
dren from using g them as a me eans of access t
dous Pressur re.
Pool and sp
n, and after pum mp shut off. Sta
on instructions could result in
e in the system , which could c
ation system, a ll system and p pump controls m
re starting syst em pump, all s
change filter co ntrol valve pos
ef valve. Do no t close filter ma
ation Hazard .
Failure to fol
nents. Straine r cover must be
culation system m, filters manua
tem componen nt is not assemb
filter manual a ir relief valve b
ore than 50 PSI I. Do not purge
s to explode, wi ith risk of sever
air purging the e pump, filter, o or piping.
USE O ONLY HAYW WARD GENUI
NS
all instructio ns
in this own ner's manual a
y and/or death h.
h are, damaged d, broken, crack
s:
on outlet cover. .
a suction outlet t sump or suctio
a mechanical b bind or swelling
ed to a large po ortion of the bo ody or limbs can
re applied direc ctly to the intes
n, cracked, mis ssing, or unsecu ured can result
y, swimsuit, ha air decorations,
al entrapment.
by a person, a m minimum of tw wo functioning s
e (i.e. floor or w wall), must be i
int.
stances to avoi
eating areas or on the backres st for such seati
ed the flow ratin ng of as listed o on Table 1.
mponent is dam maged, broken,
or not securely attached suctio
mp installed in accordance wi
al codes applica able.
m, which relieve es entrapping s suction, is reco
ugs and/or plu ugs used in wi
apment as des scribed above.
r of debris, suc ch as leaves, d
on entrapment t as described
a finite life, the e cover/grate s
damaged, bro ken, cracked,
system, pump ps and heater m must be positi
children. To r reduce risk of in njury, do not pe
. Components s such as the filt
to the pool.
pa water circula ation systems o operate under h
and clear of circ culation system m equipment du
violent separat tion of the pum
cause property damage, sever re personal inju
must be in off p position and filt
ystem valves m must be set in a
ition while syst tem pump is ru
anual air relief v valve until a ste
low safety and operation instr
e properly secu red to pump ho ousing with stra
al air relief valv e must be in op pen position. D
bled properly, d damaged, or mi
ody is in locked d position in fil
e the system w with compresse
re injury or deat th to anyone ne earby. Use only
INE REPLAC CEMENT PAR
nd on the equ
ked, missing, o or unsecured ca an cause severe
on outlet cover r that is damage ed, broken,
g of the limb.
n result in an en ntrapment.
tines through a an unprotected
in evisceration n/
finger, toe or k knuckle to be ca aught in an
suction outlets per pump must
nstalled a mini mum of three f feet (3') [1 mete
id "dual blocka age" by a user.
ing areas.
cracked, missi ing, or not secu urely attached.
on outlet comp onents immedi iately.
ith latest ASME E, APSP Standar rds and CPSC
mmended.
nterization of the pool/spa f from the
.
dirt, hair, pape er and other
above.
should be insp pected frequen ntly and
missing, or no ot securely atta ached.
oned so as to
ermit children to o use or climb
ration system, pumps, and he eaters must be
hazardous press sure during
uring pump sta rt up. Failure to
p housing and cover, and/or f filter housing
ury, or death. B
ter manual air r elief valve mus
position to allo ow system wate er to return
nning. Before s starting system m pump, fully
eady stream of water (not air o or air and water
ructions could r result in violent t separation of
ainer cover lock k ring. Before
Do not operate p pool and spa
issing. Do not o operate pool an nd spa
ter upper body . Never operat te or test the
ed air. Purging g the system wi
y a low pressur e (below 5 PSI)
RTS
ipment.
e
suction outlet
t
er]
prevent their
o
efore servicing
t
r)
th compressed
,
3