Important Information - GAH electrastream User And Installation Manual

Single and twin coil models

Hide thumbs Also See for electrastream:

User and installation instructions manual (41 pages)

Table Of Contents

Table of Contents

Important Health and Safety Information for Installers and Service Engineers

BEFORE STAR

BEFORE STARTING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARE

BEFORE STAR

TING THE INSTALLATION OF THE ELECTRASTREAM CHECK ALL COMPONENTS HAVE BEEN DELIVERED AND ARE

Health and Safety at Work Act 1974

IN SATISFACTORY CONDITION - R

IN SATISFACTORY CONDITION - Refer to 1-3.

IN SATISFACTORY CONDITION - R

Consumer Protection Act 1987

Delivery

Standard Electrastream systems will be delivered wrapped on single pallet with cylinder together with box containing control box

COSHH Regulations 1988

and loose components.

The following information is given as a requirement of the

Pre-Plumbed Electrastream systems will be delivered wrapped on single pallet with cylinder, control box and all components fully

above legislation.

assembled.

Great care is taken by GAH (HEATING PRODUCTS) LIMITED

Pack should be lifted using suitable sized pallet truck or fork lift truck.

to ensure that Electrastream systems are designed and

manufactured to meet general safety requirements when

WEIGHTS OF PACKED CYLINDERS and COMPONENTS

properly used and installed as recommended in this manual.

It is the responsibility of Users and Engineers to ensure that

i S

g n

e l

i o

S l

s y

e t

adequate protective clothing and glasses are worn when

working with the Electrastream system.

d o

l e

a P

k c

g i

t h

5 5

g k

1 L

0 3

SEALS AND INSULATION

0 6

g k

1 L

0 5

Insulation and sealing materials are used in the construction

of the Electrastream cylinders. Units are sealed and when

used in the manner for which they are intended the insulating

and sealing materials do not present any known hazard.

Storage

However always observe the following recommendations:-

Prior to installation the cylinder and box should remain on its pallet with wrapping intact and stored upright. The cylinder and

Avoid inhalation of fibres or dust, wear face mask.

components must be stored safely in a dry, frost free environment and protected from accidental damage.

Avoid eye contamination by fibres or dust - wear eye

protection.

As far as possible avoid any skin contact with Fibreglass

WARNING TO THE USER

Insulation, Glass Rope, Mineral Wool, Insulation Pads and

Ceramic Fibre.

DO NOT remove or adjust any component par

DO NOT r

emove or adjust any component par

emove or adjust any component part of the unvented water heater: contact the

In the event of hot water/steam being emitted at the dischar

In the event of hot water/steam being emitted at the discharge pipe or tundish, switch the system Off and contact installer - r

In the event of hot water/steam being emitted at the dischar

Fault Finding section 7.

If the Electrastream system develops a fault or is not operating as expected: contact the

If the Electrastr

eam system develops a fault or is not operating as expected: contact the

eam system develops a fault or is not operating as expected: contact the INSTALLER

If the Electrastr

eam system develops a fault or is not operating as expected: contact the

IMPOR

TANT TO THE INSTALLER

IMPORTANT TO THE INSTALLER

IMPOR

TANT TO THE INSTALLER

This installation is subject to Building Regulation Appr

This installation is subject to Building R

Use only manufactur

Use only manufacturer’'s r

Use only manufactur

er’'s r

er’'s recommended r

ecommended r

ecommended replacement par

ecommended r

In pursuance of a policy of constant development, GAH (HEATING PRODUCTS) LIMITED

reserve the right to change Electrastream parts or design without notice, therefore

The following Information must be pr

The following Information must be provided:-

The following Information must be pr

certain details included in this manual may not be correct at the time of printing. Any

modification and improvements detailed in this manual does not commit GAH to update

INSTALLED BY:-

any system previously supplied.

Name ............................................................................................................

Manual Part No. ...................MAN1019

Address .........................................................................................................

Manual Ref ..........................ES02

Issue ...................................13

Tel. ................................................................................................................

Date .................................... 25/02/13

Completion Date ...........................................................................................

ELECTRICS BY:-

P P P P P atent application 01514800.2

atent application 01514800.2

2010 GAH (HEATING PRODUCTS) L

2010 GAH (HEATING PRODUCTS) LTD.

2010 GAH (HEATING PRODUCTS) L

Name ............................................................................................................

Electrastr

Electrastream is a T

Electrastr

eam is a T

eam is a Trademark of GAH (HEATING PRODUCTS) L

eam is a T

rademark of GAH (HEATING PRODUCTS) L

rademark of GAH (HEATING PRODUCTS) LTD.

Address .........................................................................................................

Tel. ................................................................................................................

HTS REF GAH ELECTRASTREAM 25/02/13

Manual by Harber Technical Services Tel/Fax 01263 515444

Completion Date ...........................................................................................

E-mail:info@harbertech.co.uk

IMPORTANT INFORMATION

efer to 1-3.

i S

g n

e l

l i o

e r

P -

u l

d e

s y

e t

d o

l e

a P

k c

g i

t h

1 7

g k

P E

0 3

6 7

g k

P E

0 5

7 7

g k

1 P

5 2

t of the unvented water heater: contact the

t of the unvented water heater: contact the INSTALLER

ge pipe or tundish, switch the system Off and contact installer - r

ge pipe or tundish, switch the system Off and contact installer - refer to

ge pipe or tundish, switch the system Off and contact installer - r

egulation Appr

egulation Approval, notif

oval, notif

oval, notify the L

y the Local Authority of intention to install.

y the L

eplacement par

eplacement parts. ts. ts. ts. ts.

ovided:-

TD.

www.harbertech.co.uk

IMPORT

IMPORTANT INFORMA

IMPORT

ANT INFORMA

ANT INFORMATION

HEAL

HEALTH & SAFETY

HEAL

IMPORT

ANT INFORMA

HEAL

OTHER MATERIALS

SEALANTS, ADHESIVES AND PAINTS

Sealants, Adhesives and Paints are used in the construction of

the Electrastream components. When used in the manner for

which they are intended they do not present any known hazard.

ELECTRIC

The Cylinder Tri-Core Heater, Pump, Thermostats and Contactor

Box all have electrical supply of 230V (enough to endanger

w T

n i

l i o

life).

e r

P -

u l

d e

s y

e t

Always isolate before connection, adjustment, servicing and

repair.

d o

l e

a P

k c

g i

t h

When the Tri-Core Heater cover is removed high power live

7 7

g k

P T

5 1

electrical terminals are exposed.

ISOLATE THE TRI-CORE HEATER BEFORE REMOVING ITS

COVER.

Earth protection - Earth Continuity Conductors must be fitted

and must comply with IEE Wiring Regulations.

GAH (HEATING PRODUCTS) LIMITED will not accept

responsibility for any damage or personal injury caused

by not giving due consideration to the above safety

recommendations.

INSTALLER

INSTALLER. . . . .

INSTALLER

INSTALLER. . . . .

INSTALLER

y the L

ocal Authority of intention to install.

GAH (Heating Pr

oducts) Ltd.

GAH (Heating Products) Ltd.

GAH (Heating Pr

oducts) Ltd.

Building 846

Bentwaters Parks

Rendlesham

Woodbridge

Suffolk IP12 2TW

T T T T T el: el: el: el: el:

01394 421160

Fax:

Fax: 01394 421170

Fax:

01394 421170

email: mail@gah.co.uk

www.gah.co.uk

TH & SAFETY

TION

TH & SAFETY

TION

l P

s u

' P '

c A

u c

a l

r o t

d o

l e

a P

k c

g i

t h

0 0

5 3

g k

0 0

0 5

g k

efer to

Table of Contents

Show Quick Links

Hide quick links:

Table of Contents

Important Information - GAH electrastream User And Installation Manual

IMPORTANT INFORMATION

Hide quick links:

Related Manuals for GAH electrastream

Related Products for GAH electrastream

Table of Contents