Table of Contents
Advertisement
Important Health and Safety Information for Installers and Service Engineers
2-3
Shut Off Valves
Health and Safety at Work Act 1974
Consumer Protection Act 1987
COSHH Regulations 1988
The following information is given as a requirement of the
2 2 2 2 2
above legislation.
Great care is taken by GAH (HEATING PRODUCTS) LIMITED
to ensure that Electrastream systems are designed and
manufactured to meet general safety requirements when
STOP COCK
properly used and installed as recommended in this manual.
It is the responsibility of Users and Engineers to ensure that
adequate protective clothing and glasses are worn when
INCOMING
working with the Electrastream system.
MAINS WATER
SUPPLY WATER SHUT OFF VALVE
SEALS AND INSULATION
SEALS AND INSULATION
SEALS AND INSULATION
SEALS AND INSULATION
SEALS AND INSULATION
Insulation and sealing materials are used in the construction
of the Electrastream cylinders. Units are sealed and when
used in the manner for which they are intended the insulating
and sealing materials do not present any known hazard.
However always observe the following recommendations:-
1.
Avoid inhalation of fibres or dust, wear face mask.
2.
Avoid eye contamination by fibres or dust - wear eye
protection.
3.
As far as possible avoid any skin contact with Fibreglass
Insulation, Glass Rope, Mineral Wool, Insulation Pads and
Ceramic Fibre.
In pursuance of a policy of constant development, GAH (HEATING PRODUCTS) LIMITED
reserve the right to change Electrastream parts or design without notice, therefore
certain details included in this manual may not be correct at the time of printing. Any
modification and improvements detailed in this manual does not commit GAH to update
any system previously supplied.
Manual Part No. ...................MAN1019
Manual Ref ..........................ES02
Issue ...................................13
Date .................................... 25/02/13
P P P P P atent application 01514800.2
atent application 01514800.2
atent application 01514800.2
atent application 01514800.2
atent application 01514800.2
© © © © ©
2010 GAH (HEATING PRODUCTS) L
2010 GAH (HEATING PRODUCTS) L
2010 GAH (HEATING PRODUCTS) LTD.
2010 GAH (HEATING PRODUCTS) L
2010 GAH (HEATING PRODUCTS) L
Electrastr
Electrastream is a T
Electrastr
Electrastr
Electrastr
eam is a T
eam is a Trademark of GAH (HEATING PRODUCTS) L
eam is a T
eam is a T
rademark of GAH (HEATING PRODUCTS) LTD.
rademark of GAH (HEATING PRODUCTS) L
rademark of GAH (HEATING PRODUCTS) L
rademark of GAH (HEATING PRODUCTS) L
HTS REF GAH ELECTRASTREAM 25/02/13
Manual by Harber Technical Services Tel/Fax 01263 515444
E-mail:info@harbertech.co.uk
20
2
The Electrastream installation will have a number of shut off valves, the location of these
will be dependent on the installation - fig. 2-3a shows typical layout.
H O T W A T E R S H U T O F F V A LV E
COLD WATER SHUT OFF VALVE
COLD SUPPLY TO TAPS
WATER
SOFTENER
(OPTION)
Fig. 2-3a Typical Shut Off Valve Locations - single coil shown
IMPORTANT Before closing ANY valve, switch OFF the Electrastream
Isolating Switch.
TD.
TD.
TD.
TD.
TD.
TD.
TD.
TD.
www.harbertech.co.uk
OPERA
OPERATOR CONTROLS
OPERA
OPERA
OPERA
OTHER MATERIALS
OTHER MATERIALS
OTHER MATERIALS
OTHER MATERIALS
OTHER MATERIALS
SEALANTS, ADHESIVES AND PAINTS
Sealants, Adhesives and Paints are used in the construction of
THERMOSTATIC
the Electrastream components. When used in the manner for
SHOWER
which they are intended they do not present any known hazard.
ELECTRIC
ELECTRIC
ELECTRIC
ELECTRIC
ELECTRIC
The Cylinder Tri-Core Heater, Pump, Thermostats and Contactor
Box all have electrical supply of 230V (enough to endanger
life).
Always isolate before connection, adjustment, servicing and
repair.
When the Tri-Core Heater cover is removed high power live
electrical terminals are exposed.
ISOLATE THE TRI-CORE HEATER BEFORE REMOVING ITS
COVER.
PRV - 6 Bar
Earth protection - Earth Continuity Conductors must be fitted
and must comply with IEE Wiring Regulations.
GAH (HEATING PRODUCTS) LIMITED will not accept
responsibility for any damage or personal injury caused
by not giving due consideration to the above safety
recommendations.
GAH (Heating Pr
GAH (Heating Pr
GAH (Heating Products) Ltd.
GAH (Heating Pr
GAH (Heating Pr
Building 846
Bentwaters Parks
Rendlesham
Woodbridge
Suffolk IP12 2TW
T T T T T el: el: el: el: el:
01394 421160
01394 421160
01394 421160
01394 421160
01394 421160
Fax:
Fax:
Fax: 01394 421170
Fax:
Fax:
01394 421170
01394 421170
01394 421170
01394 421170
email: mail@gah.co.uk
www.gah.co.uk
TOR CONTROLS
TOR CONTROLS
TOR CONTROLS
HEALTH & SAFETY
HEAL
HEAL
TH & SAFETY
TH & SAFETY
TH & SAFETY
TOR CONTROLS
HEAL
HEAL
TH & SAFETY
HOT SUPPLY TO TAPS
THERMOSTATIC MIXING VALVE
oducts) Ltd.
oducts) Ltd.
oducts) Ltd.
oducts) Ltd.
2
2
2
2
2
Hide quick links:
Advertisement
Table of Contents
