Solving Common Problems - SUNWIND 420128 Instruction Manual

It is recommended that before using the heater after a period of 3
months or before the start of the heating season the owner should:
.
Check the condition of the gas cylinder.

Check the hose assembly for any wear or damage. If the hose and

regulator assembly is damaged or more than 5 years old replace
with an approved hose and regulator assembly.
Check for leaks.

Servicing shall be carried out by an authorized or qualified service
person only.
If service is required, remove the reflector hood and burner mesh
assembly to access the ignition system and gas valve.
Replace the faulty item with correct approved component. Any
replacement or
distributors/dealer.
The 3 most common problems associated with any gas heater are gas
leaks, wrong gas pressure and dirt.
DO NOT USE YOUR HEATER WITHOUT CHECKING FOR LEAKS.

Leaks can occur during shipment and installation. A simple solution
of soap and water dabbed on the fittings will bubble if a gas leak is
present.
WRONG GAS PRESSURE. Too much gas pressure may severely

damage your heater. Too little gas pressure and your heater will not
burn correctly. If your installer cannot check gas pressure, call your
gas supplier.
DUST AND DIRT. This heater requires some cleaning. Replacement

of thermocouple or pilot assembly is generally not needed. Review
CLEANING AND CARE in this manual.
SERVICING
WARNING
accessories are

SOLVING COMMON PROBLEMS

available from your local
57