Denco CAIRplus Operation Manual page 20

Shipping and Storage
4.2.1 Lifting the unit – lifting lugs on roof (provided with shipment units weighing up to 1500 kg)
Angle range
70 - 110°
Fig. 4-1: Lifting lugs for shipment units weighing up to 1500 kg
20
•
For safety reasons, wear protective clothing when lifting or transporting the unit.
•
Before lifting or shipping the unit, make sure that all doors, dampers and panels are
fixed and secured.
•
Only use lifting gear with sufficient load-bearing capacity.
•
Never use damaged lifting equipment.
•
Ropes/chains must not be knotted and/or be exposed to sharp edges.
•
Only use ropes/chains of the same length.
•
Use only the lifting lugs provided by DencoHappel!
•
Move the unit carefully without jerky movements.
•
Do not set the unit down abruptly or bump it.
•
•
•
•
•
•
•
•
•
Lifting lugs may only be used for lifting.
Do not use lifting lugs for lateral loads (pulling of unit on
sides).
The suspension angle must be between 70° and 110° (see
fig. 4-1).
Lifting lugs may only be used once.
Do not use lifting lugs for permanent suspension of units.
Do not lift any other loads together with the shipment unit.
With units for outdoor installation, ensure that the roof sheets
are not damaged by the lifting gear.
The maximum lifted weight of the shipment unit
may not exceed 1500 kg.
Use all four eyeplates to lift the shipment unit.
PR-2009-0096-GB • Subject to modifications • R8-10/2015
CAIRplus