Warranty; Introduction; Safety - Garland MWEFH-9501 Operation Manual

WARRANTY

This warranty covers defects in material and workmanship
under normal use providing that:
a) the equipment has not been accidentally or intentionally
damaged, altered or misused.
b) the equipment is properly installed, adjusted, operated
and maintained in accordance with national and local
codes and in accordance with the installation instructions
provided with this product.
c) the warranty serial number affixed to the appliance by us
has not been defaced, obliterated or removed.
d) an acceptable report for any claim under this warranty is
supplied to us.
The equipment warranty coverage remains in force for
one (1) year (parts and labor) from the date the equipment
is put into operation and two (2) years (parts only) for the
microprocessor controller, motor speed controller and upper
platen (aluminum casting and shroud).
The Garland Group agrees to repair or replace, at it's
option, any part that proves to be defective in material or
workmanship at no charge for the part or normal labor.
We assume no responsibility for installation, adjustments,
diagnosis, or normal maintenance such as: lubrication of
springs or valves. We exclude failures caused by erratic
voltage or gas supplies. We assume no responsibility for
travel costs beyond 100 miles round trip, travel other than
overland, and overtime costs of repair. We exclude broken
glass, paint and porcelain finish, surface rust, gasket
material, ceramic material, light bulbs and fuses from normal
coverage. We exclude damage or dysfunction caused by fire,
flood, and like "Acts of God" that are beyond the control of
The Garland Group.
The Garland Group's liability on a claim of warranty shall
not exceed the price of the material and/or service, which
caused the claim. This warranty is limited and is in lieu of all
other warranties, expressed or implied. The Garland Group,
our employees, or our agents shall not be held liable for any
claims of personal injury or consequential damage or loss.
This warranty gives you specific legal rights, and you may
have other rights which vary from state to state.

INTRODUCTION

The Garland clamshell grill complies with the essential
requirements of the Directives 89/109/EEC, 73/23/EEC, 89/
336/EEC, and the standards, EN60335, IEC801.2, IEC801.3,
IEC801.4, IEC801.5, IEC801.6, IEC801.11.
The Garland clamshell grill, manufactured exclusively for
McDonald's, provides a method for efficient two-sided
cooking, while accommodating a variety of products. The
unit will also serve as a flat grill, and meets all of McDonald's
standards for safety, efficiency, and cleanliness.
Always follow these safety precautions when operating the
clamshell grill.
THIS GRILL MUST be operated by persons who have been
given adequate training.
CAUTION:
OPERATED UNDER AN APPROVED HOOD SYSTEM.
DO NOT
BEEN COMMISSIONED (START-UP) BY A FACTORY
AUTHORIZED SERVICE CENTER.
DO NOT
operation manual.
DO NOT
been properly installed and grounded.
DO NOT
service and access panels are in place and fastened properly.
The Garland clamshell grill is a semi-automatic cooking
appliance. The upper platen is lowered automatically,
following the manual; two-handed initiation of the cooking
cycle, and the upper platen is raised automatically upon
completion of the cooking cycle.
When two sided cooking, the area between the upper platen
and the griddle plate should be regarded as a "danger zone".
During two sided cooking the operator must not be within
this danger zone. When used as a flat grill, then this area is
no longer a danger zone, the platens do not move.
For whatever reason, be it cleaning, maintenance, normal
operation, any exposed person must use extreme caution if
within this danger zone.
In two side cooking the upper platen remains in the lowered
position by nature of it's own weight. It is not locked down.
It can be raised by lifting of the handle on the front of the
platen, which pivots the platen about its rear mounting
point.
The clamshell grill may during its operation emit airborne
noise equivalent to a continuous A weighted sound pressure
level of 73dB(A).
5

SAFETY

THIS EQUIPMENT MUST ONLY BE
OPERATE THE GRILL UNLESS IT HAS
operate the grill without reading this
operate the clamshell grill unless it has
operate the clamshell grill unless all