Rear Suspension; Maintenance; Periodic Maintenance Checklist - Arctic Cat Jaguar Z1 Operator's Manual

REAR SUSPENSION (Every 40
Operating Hours)
NOTE: Arctic Cat recommends
that Arctic Cat Low-Temp Grease
(p/n 0636-593) be used for this
procedure.
1. Shut engine off and wait for all
moving parts to stop.
2. With the gas tank nearly empty
(less than 1/4 full), lay the
snowmobile on its left side. A
piece of cardboard should be
used to protect the finish on the
hood and belly pan.
3. Remove ice and snow buildup
from the skid frame to expose
the grease fittings.
ITEM
Brake System
Cooling System
Oil System
Engine Oil
Battery
Stop Switch
Hoses
Headlight & Taillight/Brakelight
Steering System
Throttle Control System
Drive Belt
Ski Wear Bars
Electrical Wiring
Exhaust System
Nuts, Bolts, Fasteners
Shock Absorbers
Suspension
Track Tension/Alignment
Wear Strips
Wires & Cables
Fuel System - Tank, Pump,
& Vent Hose
ACT Drive Gear Case
Heat Exchangers
Drive Clutch/Driven Pulley
Front & Rear Suspension
22
4. Lubricate the grease fittings
with low-temperature grease.

MAINTENANCE

PERIODIC MAINTENANCE CHECKLIST

INTERVAL REFER TO
Daily Page 27 Check for binding, leakage, and proper operation; lever
firmness, travel, caliper, disc, and pads
Daily Page 10 Check for leakage, damage, obstructions, coolant level
Daily Page 23-24 Check for leakage, damage, and engine oil level
2000 miles/ Page 24 Change oil and filter
Seasonal
Daily Page 10 Check for proper charge and tight connections
Page 25
Daily — Check for proper operation
Daily — Check for damage, leakage, and routing
Daily Page 36 Check for proper operation and cleanliness
Daily — Check for proper operation, tightness of bolts, and
binding
Daily Page 18 Check for binding, sticking, proper operation, throttle
cable tension, and routing
Daily Page 30 Check for wear, cracks, and fraying
Monthly Check length and width dimensions
Daily Page 38 Check for wear and damage
Weekly — Check for wear, damage, tight connections, and routing
Weekly Page 9 Check for damage, leakage, and obstructions
Weekly — Check tightness
Weekly Page 11 Check for fluid leakage and damage
Weekly Page 35 Check for damage, loose components, and proper
adjustment
Weekly Page 32 Check/adjust as necessary
Page 33
Weekly Page 39 Check for wear and damage
Weekly — Check for wear, damage, and routing
Weekly — Check for damage, wear, obstructions, and leakage
Seasonal Page 20 Change drive fluid prior to storage
Monthly — Check for wear, leakage, and damage
Monthly Page 10-11 Check for damage, abnormal noise, vibration,binding,
and sticking and clean off drive belt deposits
Monthly Page 21-22 Grease
0741-376
REMARKS
MAINTENANCE