Fuel System - Toro 30301TC Operator's Manual

2. Remove the oil filter (Fig. 22). Apply a light coat of
clean the oil to the new filter seal before screwing it on.
DO NOT OVER-TIGHTEN.
3. Add 15W-40 CE oil to the crankcase. Capacity is 4.5 l
with the filter.
FUEL SYSTEM (Fig. 23)
Fuel Tank
Drain and clean the fuel tank every 800 hours of operation
or yearly, whichever comes first. Also, drain and clean the
tank if the fuel system becomes contaminated or if the
machine is to be stored for an extended period. Use clean
fuel to flush out the tank.
Because diesel fuel is highly flammable, use caution
when storing or handling it. Do not smoke while filling
the fuel tank. Do not fill the fuel tank while the engine
is running, hot, or when th in an enclosed area. Always
fill the fuel tank outside and wipe up any spilled diesel
fuel before starting the engine. Store fuel in a clean,
safety-approved container and keep the cap in place.
Use diesel fuel for the engine only; not for any other
purpose.
Fuel Lines and Connections
Check lines and connections every 400 hours or yearly,
whichever comes first. Inspect for deterioration, damage, or
loose connections.
Draining The Fuel Filter/Water Separator
Drain water or other contaminants from the fuel filter/ water
separator daily.
1. Place a clean container under the fuel filter.
2. Loosen the drain screw on bottom of the fuel filter and
press the primer plunger until only the fuel is evident
draining into the container.
3. Tighten the drain screw.
DANGER
1
2
Figure 23
1. Fuel filter
2. Drain screw
3. Primer plunger
3
25