Table of Contents
Advertisement
18
G. Resetting the Maintenance Schedule
19
Part 10 - Start-Up Procedures for the Installer
19
A. Boiler Control Status Menu
19
B. Cascade Menu
19
C. Boiler Test Mode
19
Part 11 - Troubleshooting
20
A. Boiler Error and Fault Codes
27
B. Boiler Error
27
C. Boiler Fault
D. User Interface Display
28
Part 12 - Maintenance
29
A. Procedures
30
B. Combustion Chamber Coil Cleaning Instructions
30
C. Cleaning Water Side of Heat Exchanger
30
D. Maintaining the Condensate System
31
Part 13 - Shutdown
31
A. Shutdown Procedure
33
B. Vacation Procedure
C. Failure to Operate
34
Part 14 - Installation Checklist
35
Part 15 - Maintenance Report
38
Limited Warranty
38
Maintenance Notes
38
Customer Installation Record Form
38
Part 1 - General Safety Information
38
This boiler is approved for indoor installations only and is not
39
intended for use as a pool heater. Clearance to combustible
39
materials: 6" top, bottom, sides, and 0" back. Left side has
39
all boiler mechanical connections. Boiler must have room for
39
service: 24" front is minimum recommended service clearance.
39
(A combustible door or removable panel is acceptable front
40
clearance.) This boiler has been approved for closet installation
40
and installation on combustible flooring. Do not install directly on
40
carpeting. Install the boiler in a location where temperature and
41
pressure relief valve discharge or a leak will not result in damage
41
to the surrounding area. If such a location is not available, install
43
an auxiliary catch pan. Use only Category IV vent systems.
43
44
45
Installer - Read all instructions in this manual before installing.
45
Perform steps in the given order.
45
User - This manual is for use only by a qualified heating installer /
45
service technician. Have this boiler serviced / inspected annually
46
by a qualified service technician.
46
FAILURE TO ADHERE TO THE GUIDELINES ON THIS PAGE
46
47
CAN RESULT IN SUBSTANTIAL PROPERTY DAMAGE,
47
SEVERE PERSONAL INJURY, OR DEATH.
NOTE: If the boiler is exposed to the following, do not operate.
47
Immediately call a qualified service technician.
47
1. Fire
47
2. Damage
48
3. Water
48
Failure to follow this information could result in property
49
damage, severe personal injury, or death.
49
NOTE: Obey all local codes. Obtain all applicable permits
49
before installing the boiler.
49
50
NOTE: Install all system components and piping in such a
50
manner that does not reduce the performance of any fire rated
50
assembly.
5
52
53
53
55
55
56
56
56
56
57
62
62
62
63
63
64
64
64
64
69
69
73
75
76
WHL-016 Rev. 4.14.16
Advertisement
Table of Contents
