Recharge System; Starting System - PGO PMX Sport 50 Service Manual

(1)Troubleshooting:
A. Recharge system:
ŸNo power:
1.Battery ove r discharging
•No electrolyte in battery.
‚Battery is bleached
ƒShort circuit in Battery.
„Regulator malfunction
2.The battery wires are disconnected.
3.Fuse is broken.
4.Ignition switch is abnormal.
ŸVoltage is too low:
1.Battery recharges insufficiently.
2.The bad connection on wiring system.
3.Recharge system is abnormal.
4.Regulator malfunction.
B. Ignition system:
ŸThe sparking of spark plug is abnormal:
1.Spark plug is dead.
2.Wire connectsion is broken or short
Circuit.
•between A.C. generator and CDI sets
‚
between CDI sets and High Voltage coil.
ƒbetween CDI sets and main switch.
„between main switch and spark plug.
3.Main switch is out of order.
4.H.V. coil is not in good function.
5.CDI sets is out of order.
6.A.C. generator is not in good function.
C. Starting system:
ŸStarting motor can't rotated:
1.The fuse is broken.
2.Battery recharges insufficiently.
3.Main switch is out of order.
4.Starting motor switch is out of order.
5.Front/rear brake switch is out of order.
6.Starter relay is out of order.
7.Wire disconnects or broken.
8.Starting motor is out of order.
ŸCurrency is broken:
1.
The wiring of batter connection is not good.
2.Ignition system connection is not good.
3.Ignition system is short circuit.
4.Lamp system connection is not good or
short circuit.
ŸAbnormal recharge system:
1.The plug connection is not good.
The wire broken or short circuit.
2.Rectifier is out of order.
A.C. flywheel magneto is abnormal.
3.
D. Engine running unsmoothly:
1.Ignition primary circuit.
•
the wire or plug of wiring connection is not good.
‚main switch disconnects.
2.Ignition secondary circuit.
•Ignition coil is not in good function
‚Spark plug is dead.
ƒH.V. coil is not in good function.
„The spark plug cap is not in good function.
3.Ignition timing
•A.C. generator is out of order.
‚A.C. coil is not in good function.
ƒC.D.I. sets is out of order.
ŸStarting motor runs weakly.
1.Battery recharges insufficiently.
Wiring system disconnects.
2.
The alien objects drop in the motor or gear.
3.
ŸStarting motor can rotate, but
engine can't start up.
1.Starting gear is abnormal.
Starting motor is reversedly rotating.
2.
3.Battery is out of order.