Table of Contents
Advertisement
Quick Links
INSTALLER: Leave this manual with party responsible for use and operation.
OwNER: Retain this manual for future reference.
NOTICE: DO NOT discard this manual!
Models:
wARNING!
Risk of Fire!
Do not install glass doors on this fireplace.
Glass doors could cause overheating of
adjacent structures.
DANGER
Outdoor Lifestyles by Hearth & Home Technologies • Palazzo Installation Manual • 4082-311 Rev. A • 06/08/15
Installation Manual
Installation and Appliance Setup
DANGER
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
wARNING: For Outdoor Use Only.
wARNING
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
An LP-cylinder not connected for use shall not
be stored in the vicinity of this or any other
appliance.
wARNING:
Improper installation, adjustment,
alteration, service or maintenance can cause injury or property
damage. Read the installation, operating and maintenance
instructions thoroughly before installing or servicing this
equipment.
CARBON MONOXIDE HAZARD
This appliance can produce carbon monoxide
which has no odor.
Using it in an enclosed space can kill you.
Never use this appliance in an enclosed space
such as a camper, tent or home.
1
Advertisement
Table of Contents
Related Manuals for Outdoor Lifestyles DPALG-48
Summary of Contents for Outdoor Lifestyles DPALG-48
- Page 1 Installation Manual Installation and Appliance Setup INSTALLER: Leave this manual with party responsible for use and operation. OwNER: Retain this manual for future reference. NOTICE: DO NOT discard this manual! DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame.
-
Page 2: Table Of Contents
Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. • NOTICE: Used to address practices not related to personal injury. -
Page 3: Installation Standard Work Checklist
Installation Standard work Checklist ATTENTION INSTALLER: Follow this Standard Work Checklist This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this installation manual. Customer: Date Installed: Lot/Address: Location of Fireplace: Installer: Model (circle one): ODPALG-48 Dealer/Distributor Phone #... -
Page 4: Product Specific And Important Safety Information
Product Specific and Important Safety Information A. Appliance Certification C. High Altitude Installations NOTICE: If the heating value of the gas has been reduced, MODEL: ODPALG-48, ODPALGST-48 these rules do not apply. Check with your local gas utility or authorities having jurisdiction. LABORATORY: Underwriters Laboratories, Inc. (UL) When installing above 2000 feet elevation: TYPE: Outdoor Decorative Gas Appliances STANDARD: ANSI Z21.97-2014, CSA 2.41-2014... -
Page 5: Getting Started
Getting Started A. Design and Installation Considerations Installation and service of this appliance should be performed by qualified personnel. Hearth & Home The Palazzo series gas appliance is designed for outdoor Technologies recommends HHT use and may be installed as a stand alone unit or built Factory Trained or NFI certified into a wall. It may be installed in screened porches and professionals. -
Page 6: Inspect Appliance And Components
C. Inspect Appliance and Components • Carefully remove the appliance and components from the packaging. • Remove noncombustible material located on front of the appliance. • Remove crystal media which is packaged separately and located beneath the firebox. • Remove wall control which is located on the top standoff. • Remove blue protective coating. • Report any damaged in shipment to your dealer. • Read all of the instructions before starting the instal- lation. Follow these instructions carefully during the installation to ensure maximum safety and benefit. WARNING! Risk of Fire or Explosion! Damaged parts could impair safe operation. -
Page 7: Framing And Clearances
Framing and Clearances A. Appliance Dimension Diagrams Dimensions are actual appliance dimensions. Use for reference only. For framing dimensions and clearances refer to Figure 3.3 and Figure 3.4. ODPALG-48 Gas & Electric Connections Figure 3.1 Appliance Dimensions - ODPALG-48 Outdoor Lifestyles by Hearth & Home Technologies • Palazzo Installation Manual • 4082-311 Rev. A • 06/08/15... - Page 8 ODPALGST-48 Gas & Electric Connections Figure 3.2 Appliance Dimensions - ODPALGST-48 Outdoor Lifestyles by Hearth & Home Technologies • Palazzo Installation Manual • 4082-311 Rev. A • 06/08/15...
-
Page 9: Clearances To Combustibles
B. Clearances to Combustibles When selecting a location for the appliance it is important to consider the required clearances to walls (see Figure 3.3, 3.4, 3.5 & 3.6). WARNING! Risk of Fire or Burns! Provide adequate clearance around air openings and for service access. Due to high temperatures, the appliance should be lo- cated out of traffic and away from furniture and draperies. - Page 10 ODPALG-48 SINGLE SIDED NOTICE: Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY. Illustrations/diagrams are not drawn to scale. Actual installation may vary due to individual design preference. Note: If this surface is inside the building’s warm air envelope..then this surface N o t e: Fo r a c t u a l a p p l i a n c e must be an exterior...
- Page 11 ODPALGST-48 SEE THROUGH NOTICE: Illustrations reflect typical installations and are FOR DESIGN PURPOSES ONLY. Illustrations/diagrams are not drawn to scale. Actual installation may vary due to individual design preference. N o t e : F o r a c t u a l a p p l i a n c e dimensions refer to Section 3.A.
-
Page 12: Vent Termination Minimum Clearances
C. Vent Minimum Clearances (See Note 2) Alcove J or K = FIREPLACE OPENING = AIR SUPP LY INLET = AREA WHERE FIREPLACE IS NOT PERMITTED = 24 in..clearances above grade, 9 in. -
Page 13: Hearth Extension/Floor Protection
WARNING! Risk of Fire! Com- ply with all minimum clearances to combustibles as specified. Framing or finishing material closer than the Ceiling or Overhang minimums listed must be constructed 50 in. entirely of non-combustible materials (1270 mm) minimum (i.e., steel studs, concrete board, etc). 88 in. -
Page 14: Appliance Preparation
Appliance Preparation A. Securing and Leveling Appliance CAUTION! Risk of Cuts, Abrasions or Flying Debris. Wear protective gloves and safety glasses during instal- lation. Sheet metal edges are sharp. Position, level, and secure the appliance. • Place the appliance into position on either a wood or noncombustible continuous flat surface. • Level the appliance from side to side and front to back. • Shim the appliance with noncombustible material, such as sheet metal, as necessary. -
Page 15: Electrical Information
Electrical Information C. Installing the Electrical A. wiring Requirements Note: The Palazzo is supplied with two rubber grommets Note: The Palazzo appliance MUST be connected to installed on the left side of the appliance for gas and a GFCI (Ground Fault Circuit Interrupt) protected circuit electrical connections. See Figure 3.1 & 3.2. A cover breaker. plate is also provided on the right side of the appliance in the event that gas and electrical must be run from WARNING! Risk of Shock or Explosion! DO NOT wire... - Page 16 • Disassemble Junction Box. See Figure 5.3. Figure 5.3 Junction Box • Route a minimum 14/2 w/ground electrical wiring through hole provided on the left side of the appliance. • Wire & Assemble Junction Box. See Figure 5.4. Grounding connection to box (if box has a grounding terminal) Outlet Wire connector Junction LINE cable brings power from the GFCI Circuit Figure 5.4 wiring...
-
Page 17: Wiring Diagram
wiring Diagram Figure 5.6 Outdoor Lifestyles by Hearth & Home Technologies • Palazzo Installation Manual • 4082-311 Rev. A • 06/08/15... -
Page 18: Wall Switch Control Panel
D. wall Switch Control Assembly The Palazzo series outdoor gas appliance is supplied with a wired wall switch control panel, a control mounting box with cover, and trim ring. See Figure 5.7. Wall Switch Wires Control Mounting Box Mounting With Cover Trim Ring Control Panel Cover Figure 5.8 wall Switch Mounting Figure 5.7 wall Box Cover • The wall switch control assembly is shipped prewired and mounted on appliance top standoff. -
Page 19: Gas Information
Gas Information A. Fuel Conversion wARNING • Make sure the appliance is compatible with available gas Fire Risk. types. Explosion Hazard. • The Palazzo series gas appliance is supplied from High pressure will damage valve. Low the factory for use with natural gas. If a propane (LP) pressure could cause explosion. conversion is required, kit LPK-ODPALG-48 must be • Disconnect gas supply piping BEFORE purchased in order to convert the unit for use with... -
Page 20: Valve Access
D. Valve Access • Pipe incoming gas line into lower compartment. • Connect incoming gas line to the 1/2 in. (13 mm) The valve and controls are located in the appliance con- connection on manual shutoff valve. trol box. See Figure 6.2. Prior to finishing materials: The control box and controls can be accessed from the front of the appliance, prior to finishing materials being added to the face of the appliance. -
Page 21: High Altitude Installations
After finishing: • Remove screws securing control box upper access panel. Once finishing materials are added to the face of the ap- • Remove control box upper access panel. pliance, the control box and controls MUST be accessed See Figure 6.6. through the firebox. • Make sure unit is off and cool. • Remove media from hearth pan. • Remove screws securing hearth pan to firebox bottom. • Lift and remove hearth pan, set aside. See Figure 6.4. Control Box Upper Access Panel Figure 6.6 Upper Access Panel E. -
Page 22: Finishing
Finishing A. Facing Material B. Mantel and wall Projections The fireplace structure can be covered with any non- WARNING! Risk of Fire! Comply with all minimum clear- combustible material. Refer to Section 1.D. ances to combustibles as specified. Framing or finishing material closer than the minimums listed must be con- It is possible for the face of the appliance above the ap- structed entirely of noncombustible materials (i.e., steel pliance opening to show signs of soot. - Page 23 Mantel Projections Note: All measurements in inches. 50 in. minimum to ceiling 35” 34” 33” 32” 31” 30” 29” 28” 27” 26” 25” 24” 23” 22” 21” 20” 19” 18” Firebox Opening Figure 7.3 Minimum Vertical and Maximum Horizontal Mantel Dimensions For Combustible Materials Outdoor Lifestyles by Hearth & Home Technologies • Palazzo Installation Manual • 4082-311 Rev. A • 06/08/15...
- Page 24 Good Faith Guidelines for TV Installation’s above a Typical Gas Fireplace TV recessed into the wall TV on the wall Noncombustible Mantel (required) 6” Min. 14” Min. 14” Min. 12” 12” 12” 12” Min. Min. Measured from top of rebox opening. Notes: 1.
-
Page 25: Appliance Setup
Appliance Setup A. Remove the Shipping Materials F. Remove Media Placement Template Remove shipping materials from inside the firebox and Remove screw attaching the media placement template remove the blue plastic coating from the firebox. and remove. See Figure 8.2. Do not discard template. WARNING! Risk of Fire! Close the ball valve before in- stalling the splatter guard to prevent accidental lighting. -
Page 26: Reference Materials
• Media-Amber-48 Outdoor Lifestyles, a brand of Hearth & Home Technologies 7571 215 Street West, Lakeville, MN 55044 www.hearthnhome.com Please contact your Outdoor Lifestyles dealer with any questions or concerns. For the location of your nearest Outdoor Lifestyles dealer, please visit www.hearthnhome.com. Printed in U.S.A. - Copyright 2014 26...