Natural Gas Requirements - Kalamazoo K750GS Use And Care Manual

Natural Gas Requirements

Verify the type of gas your grill has been configured for by the factory by checking the serial
tag inside the door of the grill cabinet. Grills configured for natural gas (NG) are orificed
differently than grills configured for liquid propane (LP) gas. Grills configured for use with
natural gas are shipped with a gray hose with a quick-connect fitting.
Connection: Quick-connect hose assembly (included) connects to the grill via 0.5" NPT male
with a 0.375" flare adapter (included).
Input Pressure: 7.0" W.C.
Operating Pressure: 7.0" W.C. (cooktop burners) and 3.5" W.C. (all other burners via
additional regulator installed inside grill).
IMPORTANT:
Always close gas supply shut-off valve before disconnecting the grill gas supply hose.
IMPORTANT:
An installer-supplied safety shut-off valve MUST be installed on the
natural gas supply line for the grill. The valve should be easily accessed and
located between 3 and 20 feet away from the grill.
All gas connections should be made by a qualified
technician. The installation and all installer-supplied
parts must conform to local codes. In the absence
of local codes, the installation and all parts should
conform to the National Fuel Gas Code, ANSI Z223.1/
NFPA 54 or Natural Gas and Propane Installation Code,
CSA B149.1.
All pipe sealants must be an approved type.
Grill BTUs: See serial tag.
IMPORTANT: Diameter and length of the gas supply
pipe may limit the pressure and BTU delivery of gas to
the grill. The installer must ensure proper delivery to
the grill or it will not operate properly.
The appliance and its individual shut-off valve must be
disconnected from the gas supply piping system during
any pressure testing of that system at pressures in
excess of 1/2 psi (3.5 kPa).
During any pressure testing of the gas supply piping
system at test pressures equal to or less than 1/2 psi
(3.5 kPa), the appliance must be isolated from the
system by closing its individual manual shut-off valve.
1.800.868.1699
FIGURE 3
Factory-supplied
1/2" Gas Hose
Installer Supplied Shut-off Valve
Must be Easily Accessible
Regulator 3.5" WC
7