SET UP COOKING SURFACE AND OPTIONS CONTROL KNOBS / LIGHTING INSTRUCTIONS ADJUSTING THE AIRFLOW TURN OFF INSTRUCTIONS COOKING WITH YOUR KALAMAZOO OUTDOOR GOURMET GRILL A NOTE FROM THE DESIGNER KALAMAZOO OUTDOOR GOURMET LIMITED WARRANTY PRODUCT REGISTRATION INFORMATION FOR YOUR SAFETY If you smell gas: 1.
Kalamazoo Outdoor Gourmet™ grill. When properly cared for, Kalamazoo Outdoor Gourmet products will give safe, reliable service for many years. However, extreme care must be used since the grill produces intense heat and can increase accident potential.
• Clean the tubes completely if you find any such obstructions. • Do not operate the Kalamazoo Outdoor Gourmet grill if there is a gas leak present. Do not use a flame to check for gas leaks. • Do not store cover or anything flammable on or in the storage area under the grill.
National Fuel Gas Code: ANSI Z 223.1, or CAN/CGA-B149.1, National Gas Installation Code or CAN/CGA-B149.2, Propane Installation Code. The regulator supplied with the Kalamazoo Outdoor Gourmet grill must be used. This regulator is set for 11 inches of water column (pressure).
LP tank in a car on a hot day). • The Kalamazoo Outdoor Gourmet grill requires that the LP cylinder be 20-lb. Size (18 ¼ inches high, 12 ¼ inches in diameter).
REFILLING THE LP TANK Removal of the LP tank Open the door on the back of the grill Close tank valve (turn clockwise) Unscrew counter clockwise brass fitting on regulator Lift tank out Take LP tank to a “Gas Propane” dealer...
Hand tighten only). See diagram below. 3. Mix soap and water. 4. Open the tank valve. Make sure grill knobs are in the "OFF" position. 5. Check for leaks by wetting the fitting with the soap and water solution and watching for bubbles.
Page 9
1/2 psi (3.5 kPa). NOTE: Kalamazoo Outdoor Gourmet is not responsible for improper tank hookup. Kalamazoo Outdoor Gourmet 1.800.868.1699...
Keep the ventilation openings on back panel of the LP Tank enclosure free and clear from debris at all times. PERIODIC CLEANING CAUTION: Turn the Kalamazoo Outdoor Gourmet grill OFF and wait for it to cool before cleaning. Every Kalamazoo Outdoor Gourmet grill has all stainless steel surfaces, inside and out.
Igniters click, but the igniter probes are not sparking. If problems cannot be corrected by using these methods, please contact Kalamazoo Outdoor Gourmet Customer Service at 800-868-1699. IMPORTANT NOTE ON GAS HOSE: If it is evident there is excessive abrasion or wear, or the hose is cut, it must be replaced prior to the outdoor cooking gas appliance being put into operation.
• Never store a spare LP tank under or near the Kalamazoo Outdoor Gourmet grill. • If the Kalamazoo Outdoor Gourmet grill is stored for a long period of time it should be checked for gas leaks and obstructions in the burner tubes before using. (See Section “General Maintenance”)
Getting Started Open door at rear of grill. • If using LP, place tank inside. Attach LP regulator (supplied with grill) to tank (see page 6 for • instructions and warnings). If using Natural Gas, connect gas supply line to quick connect gas line supplied with grill.
Page 15
Three sets are included with The Edo Grill. (One set shown for clarity.) Note: The ceramic holders may be positioned to “personalize” the grill performance. When placed tightly together, the bulk of direct flame will be subdued by the ceramics providing a more subtle heat distribution.
Page 16
OPTIONS There are many accessories available for your Kalamazoo Outdoor Gourmet Edo grill. Mix and match any or all of these to customize your grill. To view these items visit our website at www.kalamazoogourmet.com.
DRIP PAN • Each Edo Gas Grill comes with a stainless steel Main Burner Grease Drawer to be placed inside the grill to collect drippings. See page 13 for placement. Check the Grease Drawer before each use. Remove excess grease to avoid a grease fire in the Grease Drawer.
WARNING: Check hose before each use of grill for wear, nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the Kalamazoo Outdoor Gourmet grill. Replace using only the Kalamazoo Outdoor Gourmet authorized replacement manifold assembly.
Adjusting Air Flow Burner Flame Pattern Kalamazoo Outdoor Gourmet burners have been factory set for the correct air and gas mixture. Airflow adjust is not necessary for the main burner. The correct flame pattern is shown. If the flames do not appear to be uniform in length on the burner tube, follow the burner cleaning procedures.
COOKING WITH YOUR KALAMAZOO OUTDOOR GOURMET GRILL The Kalamazoo Outdoor Gourmet grill should not be moved when operating or when hot. You can adjust flame for left and right burners individually as desired. Preheating After lighting, turn burners to “High.” Preheating to between 500 and 550°F (260 and 290°C) will take 15 to 20 minutes depending on conditions such as air temperature and wind.
Page 21
On behalf of the entire Kalamazoo Outdoor Gourmet team, I wish you and your family the very best in backyard entertaining. Great food…family… &...
Or you may ship us the old part, and we will then ship the replacement part at no Shipping charge. Charges for the old/replaced part are refunded to you at the same rate as is calculated for Kalamazoo Outdoor Gourmet to ship the new part.
PRODUCT REGISTRATION IMPORTANT: YOU MUST REGISTER YOUR PRODUCT WITH KALAMAZOO OUTDOOR GOURMET IN ORDER TO ACTIVATE YOUR WARRANTY. YOU MAY DO SO BY CALLING 1-800-868-1699 AND GIVING US THE INFORMATION BELOW OR EMAILING US REGARDING YOUR PRODUCT REGISTRATION AT CUSTOMERSERVICE@KALAMAZOOGOURMET.COM.
Need help?
Do you have a question about the Edo and is the answer not in the manual?
Questions and answers