Superior DRL3042TEN Installation And Operation Instructions Manual page 58

Innovative Hearth Products
Superior™ DRL3000 Linear Direct-Vent Gas Fireplaces
Installing the glass door
1. Visually inspect the gasket on the backside of the glass door.
2. While holding the glass door by the sides, hook the top edge onto the fireplace, and swing the bottom of the
3. Align the screw holes below the glass door with the holes in the fireplace, and secure using the three (3)
4. For cleanface installations, install the modesty panel (Page 43).
5. Install barrier.
Removing the glass door
1. Remove barrier.
1. For cleanface installations, remove the modesty panel (Page 43).
2. Remove the three (3) screws beneath the door (Figure 57).
3. Swing the bottom of the glass door away from the fireplace to a 45° angle.
4. Carefully grip the door at the top and bottom, and remove it from the fireplace. Place the door in a safe location
Figure 52: Glass Door
NOTICE: All DTL3000 model fireplaces
include a barrier to reduce the risk of burns
from hot viewing glass. This barrier in the
fireplace is a screen shown to the right.
58
NOTE: The gasket surface must be clean, free of irregularities, and seated firmly. Ensure it is properly located.
Make sure the bead is not rolled into the channel at the top of the door, but remains flat against the top of
the glass.
glass door gently in towards the fireplace ensuring that the gasket seats evenly as the door draws shut.
NOTE: If the lower flange of the door does NOT clear the lower front frame of the fireplace, ensure the door
UPPER mounting flange is completely and properly engaged on the fireplace frame BEFORE INSERTING THE
SCREWS. Proper door alignment and sealing are important to the operation and performance of the fireplace.
Ensure the door seal is contacting the frame and that no air leaks are present.
provided screws (Figure 57).
for later reinstallation.
Glass Door
Rating plate and lighting instructions
are attached to door bracket.
42" Barrier J7427
54" Barrier J7426
Operation
900079-02 05/2015