Lower Front Access Panel; Condenser Coil Access Panel; Lubrication; Carbonator Water Pump Motor - Cornelius FCB 3 H.P. POST-MIX DISPENSER Installation & Service Manual

LOWER FRONT ACCESS PANEL

Remove two screws securing lower front panel, then pull panel down to remove from Unit.

CONDENSER COIL ACCESS PANEL

Pull out on top of condenser coil access panel, then lift panel up and out to remove.

LUBRICATION

CARBONATOR WATER PUMP MOTOR

(see Figure 13)
The carbonator water pump motor bearings must be lubricated periodically. Refer to oiling instructions on motor.
DO NOT OVER OIL.
SERVICING DISPENSING VALVES CAGED O-RINGS AND FREEZE CYLINDERS DRIVE
SHAFT/SEAL ASSEMBLIES
Servicing Dispensing Valves Caged O-Rings.
(see Figure 3)
NOTE: Dispensing valves caged O-Rings should be serviced (lubricated) every six months and O-Rings
should be replaced once a year.
312026000
SPRING HOUSING
TORSION SPRING
SPRING FITTING
DISPENSING
VALVE BODY
CAGED O-RING
VALVE
LEVER
SLEEVE
SPRING
KNOB

FIGURE 3. SELF-CLOSING DISPENSING VALVE

RETAINING
SCREW(2)
HOLD-DOWN
PLATE(2)
28