APRILIA RS 50 - 1999 Manual page 47

Component
Front and rear disc brakes
Throttle
2 stroke oil/
transmission oil
Wheel/tyres
Brake lever and pedal
Steering
Clutch
Side stand
Component nuts,
bolts and other fasteners
Drive chain
Fuel tank
Coolant

Engine stop switch ( - )
Lights, warning lights
and electrical devices
Check brake operation, lever and pedal play, fluid levels. Check the pads for excessive
wear, check the discs for condition. If the discs are unduly scored or show signs of heat
discoloration, do not ride the motorcycle. Check both the tire brake systems for evidence
of leaks. If there are leaks, do not ride the motorcycle.
Make sure that it works smoothly and that it is possible to open and close it completely, in
all steering positions. If necessary, adjust and/or lubricate it.
Check and/or top up if necessary.
Check the tyre surface, the inflation pressure, wear and tear and any damage.
Make sure they work smoothly and are properly lubricated.
Make sure that the fork head rotates through its entire range without fouling of any kind.
Make sure that the fork stops touch the frame at full left and full right fork lock.
Check the play of the clutch lever. Ensure that the clutch operates without jerking or slip-
ping.
Make sure that it works smoothly and that the spring tension brings it back to its normal
position.
If necessary, lubricate joints and hinges.
Make sure that the safety switch on the side stand operates correctly.
Check that all fasteners are tight and properly torqued.
Check the slack.
Check the fuel level and top up if necessary.
Make sure that there are no fuel leaks.
Make sure that the filler cap is properly tightened.
With the engine cold, check the coolant level. Make sure that it is at the prescribed level.
Make sure that it functions correctly.
Check the proper functioning of all the lights and the horn.
Do not ride if any of these are not functioning properly.
Check Page
36, 37
38, 72
73
36, 60
44
40
–
41
74, 75
–
66, 67
35, 69, 87
42, 43
31
77 – 86
?
use and maintenance RS 50 47