Table of Contents
Advertisement
(10) Rubber Hose and Anti-Vibration Rubber Inspection/Replacement
Check
Replace
< Note >
If the rubber hoses (such as fuel, oil, coolant, air and drain) have been hardened or
deteriorated, replace them with the new.
Request the authorized distributor where the generator was purchased to replace the
rubber hose and anti-vibration rubber.
(11) Flushing Liquid in Spill Containment
Check
① Set a container to collect liquid from the flushing port of the drain
valve on the front of this generator.
② Remove the drain valve plug (R 1/2") and open the valve lever
< Note >
When removing or attaching the plug, hold the drain valve fixed
using a spanner or similar tool and turn the plug.
If oil or other liquid is mixed in with the flushed liquid, this indicates
that there is an oil leak. In such case, check for the leak location.
The types of liquids that can accumulate in the spill containment
include oil, fuel, coolant water and battery fluid such that it is not
possible to distinguish between rain water and other liquids.
Dispose of flushed liquids according to the related laws and
regulations.
③ Close the valve lever after the liquid has been flushed, and apply
sealant coating to the plug or wrap it in seal tape and reinsert it.
(12) Spill Containment Cleaning/Inspection
WARNING : INJURY
Do not lift up the unit using tie downs. Use of such could result in the generator falling.
No persons should be under a lifted generator.
CAUTION : INJURY
Always be sure to use lifting hooks when lifting up the generator, and raise it
slowly at a completely vertical angle.
Personnel performing lifting work must wear protective gear such as helmets,
safety shoes and gloves.
Do not move the generator during operation.
Check
Clean
Separate the spill containment from this generator to clean and inspect the spill
containment.
Daily
Every 2 years
Daily
Daily
Every 500 hours
34
Drain Faucet Lever
Plug(R1/2")
Drain
Loosen
Fixing
Tighten
Plug
Drain Faucet
Drain Faucet
Lever
Close
Open
Advertisement
Table of Contents
