MQ Power WHISPERWATT Series Operation Manual page 29

FUEL CHECK
DANGER
Fuel spillage on a hot engine can cause
a fire or explosion. If fuel spillage occurs,
wipe up the spilled fuel completely to prevent
fire hazards. NEVER smoke around or near
the generator. ALWAYS shut down the
engine prior to cleaning up any spilled fuel.
Refilling The Fuel System
NOTICE
DO NOT refuel while the engine is running.
CAUTION
ONLY properly trained personnel who have read
and understand this section should refill the fuel tank
system.
ALWAYS fill the fuel tank (Figure 29) with clean, fresh
#2 diesel fuel. DO NOT fill the fuel tank beyond its capacity.
Pay attention to the fuel tank capacity when replenishing
fuel. The fuel tank cap must be closed tightly after filling.
Handle fuel in a safety container. If the container does
not have a spout, use a funnel. Wipe up any spilled fuel
immediately.
40 40
INTERNAL
FUEL TANK
Figure 29. Fuel Tank
DCA40SSKU4F2 60 HZ GENERATOR • OPERATION MANUAL — REV. #2 (08/30/22) — PAGE 29
Refueling Procedure
1. Level Tanks — Make sure fuel cells are level with the
2. Open cabinet doors on the "right side" of the generator
FUEL
CAP
INSPECTION/SETUP
WARNING
Diesel fuel and its vapors are dangerous
to your health and the surrounding
environment. Avoid skin contact and/or
inhaling fumes.
ground. Failure to do so will cause fuel to spill from the
tank before reaching full capacity (Figure 30).
CAUTION
ALWAYS place the trailer on firm, level ground before
refueling to prevent spilling and maximize the amount
of fuel that can be pumped into the tank.
=
Level Ground
Figure 30. Only Fill On Level Ground
NOTICE
ONLY use #2 diesel fuel when refueling.
(from the generator control panel position). Remove
the fuel cap and fill the tank (Figure 31).
DIESEL
FUEL
Figure 31. Fueling The Generator
DO NOT fill on
unlevel ground
!
!
Level Ground
FUEL TANK
FILLER PORT