Gearbox - Skoda Octavia II 2004 Maintenance Manual

Octavia II 2004 ➤ , Octavia II 2010 ➤
Maintenance - Edition 01.2018
4

Gearbox

⇒ "4.1 6-speed automatic gearbox 09G: check ATF level and
quality and top up ATF if necessary", page 108
⇒ "4.2 6-speed gearbox DSG: Change gear oil, replace oil filter",
page 113
⇒ "4.3 Changing the oil in the four-wheel drive clutch",
page 118
4.1 6-speed automatic gearbox 09G: check
ATF level and quality and top up ATF if
necessary
Special tools and workshop equipment required
♦ Vehicle Diagnosis, Measurement and Information System -
VAS-
Test conditions
• Gearbox must not be in the emergency running mode.
• Vehicle on level ground.
• With selector lever in "P" position, let the engine idle.
• Air conditioning and heating switched off.
• ⇒ Vehicle diagnostic tester connected, function vehicle self-
diagnosis and vehicle system "02 - gearbox electronics" se‐
lected.
• The ATF temperature must not be higher than 30 °C for be‐
ginning the test, if necessary first the gearbox must be cooled
down.
Note
The ATF temperature is read off at the ⇒ Vehicle diagnostic
♦
tester.
The ATF level changes with ATF temperature.
♦
Checking ATF level when ATF temperature is too low may re‐
♦
sult in over-filling.
Checking ATF level when ATF temperature is too high may
♦
result in under-filling.
Both over-filling as well as under-filling affect gearbox opera‐
♦
tion.
If a dark colour of the oil or water in the oil is noticed during a
♦
quality inspection of the gearbox oil, the oil must be changed
⇒ automatic 6-speed gearbox 09G; Rep. gr. 37 . The oil must
be clean and must not contain any additives.
Only ATF available as spare part should be used in the auto‐
♦
matic gearbox 09G. Other oils can lead to functional problems
or to failure of the gearbox, part number ⇒ Electronic cata‐
logue of original parts .
108
4. Gearbox
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted
unless authorised by ŠKODA AUTO A. S. ŠKODA AUTO A. S. does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by ŠKODA AUTO A. S.�