Transporting Batteries; General Instructions On Handling Batteries; Handling Damaged Batteries Correctly - Invacare FDX User Manual

• Be aware that for temperatures below 20 °C, the
nominal battery capacity starts to decline. For example,
at -10 °C the capacity is reduced to about 50 % of the
nominal battery capacity.
• To avoid damaging the batteries, never allow them to
be fully discharged. Do not drive on heavily discharged
batteries if it is not absolutely necessary, as this will
strain the batteries unduly and shorten their life
expectancy.
• The earlier you recharge the batteries, the longer they
live.
• The depth of discharge affects the cycle life. The harder
a battery has to work, the shorter is its life expectancy.
Examples:
– One deep discharge stresses the same as 6 normal
cycles (green /orange display off).
– The battery life is about 300 cycles at 80 % discharge
(first 7 LED off), or about 3000 cycles at 10 %
discharge (one LED off).
The number of LED can vary depending on
the remote type.
• Under normal operation, once a month the battery
should be discharged until all green and orange LED are
off. This should be done within one day. A 16 hour
charge afterwards is necessary as reconditioning.

7.2.7 Transporting Batteries

The batteries supplied with your mobility device are
not hazardous goods. This classification is based on the
German GGVS Hazardous Goods Road Transport Ordinances,
and the IATA/DGR Hazardous Goods Rail Transport / Air
Transport Ordinances. Batteries may be transported without
1541361-N
restrictions, whether by road, rail or by air. Individual
transport companies have, however, guidelines which can
possibly restrict or forbid certain transport procedures.
Please ask the transport company regarding each individual
case.

7.2.8 General Instructions on Handling Batteries

• Never mix and match different battery manufactures or
technologies, or use batteries that do not have similar
date codes.
• Never mix gel with AGM batteries.
• The batteries reach their end of life when the drive
range is significantly smaller than usual. Contact your
provider or service technician for details.
• Always have your batteries installed by a properly
trained mobility device technician or a person with
adequate knowledge. They have the necessary training
and tools to do the job safely and correctly.

7.2.9 Handling Damaged Batteries Correctly

CAUTION!
Corrosion and burns from acid leakage if
batteries are damaged
– Remove clothes that have been soiled by acid
immediately.
After contact with skin:
– Immediately wash affected area with lots of
water.
After contact with eyes:
– Immediately rinse eyes under running water for
several minutes; consult a physician.
Controls System
89