Troubleshooting Convection-Oven Blower; Owner's Manual 1191904 Rev 2 (5/14 - Southbend S Series Owner's Manual

T
ROUBLESHOOTING
T
ROUBLESHOOTING
Before attempting to service or replace any electrical component, make sure power source has been disconnected.
When changing motor or servicing range, always verify that blower wheel rotation is clockwise when looking into the
oven cavity.
The appropriate wiring diagram for the oven can be found on the rear of the oven (as well as at the end of this section of
this manual).
Figure 9
Convection-Oven Blower Runs Intermittently
DISCONNECT POWER AT CIRCUIT BREAKER.
Check all wiring for loose connections or breaks.
Remove the cover from the junction box on the back of the range.
Disconnect the black wire and place an ammeter in the circuit.
CAUTION: Check that the ammeter is rated for at least 40
amperes! Reconnect the power to the range and turn on the
blower switch while watching the ammeter. The reading should
surge and then return to the rated current of the motor when
running at high speed. If the measured current exceeds the motor
rating, replace the blower motor.
PAGE 26 OF 31
C O
ONVECTION-
WARNING
CAUTION
Convection-oven blower runs intermittently.
Does the problem
No
occur only when the oven
is hot?
B
VEN LOWER
Yes
Check that there are no air-flow obstructions around the range.
Check that the blower motor is not pressing against the wall
behind the range.
Check that the blower motor air vents are not obstructed.
Check for excessive grease and dust buildup on the motor.
Check for sources of excessive heat behind the range.
Check for hot-air leaks around the motor pocket.
With the blower turned ON, turn the oven thermostat to OFF and
allow the oven to cool. If the blower motor runs continuously
when the oven is cool, turn the oven thermostat to the highest
setting. If the blower motor shuts off when the oven becomes hot,
and if there are no sources of excessive heat around the blower
motor, replace the blower motor.

OWNER'S MANUAL 1191904 REV 2 (5/14)

S S R
ERIES ESTAURANT
R
ANGES