Slide-Out Systems; Electric Operation; Extending The Room - Jayco 2016 White Hawk Owner's Manual

SECTION 5 – SLIDE-OUT SYSTEMS
The gears can be stripped out if the room is manually retracted/extended to its fullest
extent and the operator continues to rotate manual override. Any damage due to
misuse of the Manual Override feature will disqualify any and all claims to the
Limited Warranty.
Power r® Slideout
Gea
The Power Gear® electric slideout is a rack and pinion design operated by a 12 Volt DC
electric motor. It consists of 4 major components:

Inner rail assemblies to support the room weight.

A 12 Volt DC gear motor to operate the room using power from the onboard battery.

A manual override that allows you to extend or retract the room in the event of a loss
of power.

A control that gives the user full control of room movement, in or out. The control
has a sensing capability that stops the motor when the room is fully extended or
retracted.
NOTE: For long-term storage: It is recommended the room be closed (retracted).

Electric Operation


Always make sure the slideout room path is clear of people and objects
before and during operation of the slideout room.

Always keep away from the slide rails when the room is being operated.
The gear assembly may pinch or catch on loose clothing causing personal
injury.

Install transit bars (if so equipped) on the slideout room during storage
and transportation.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN
SERIOUS INJURY OR DEATH.

Extending the room

1. Level the unit.
2. Main Power switch at stepwell (locations may vary)
must be ON.
3. Verify the battery is fully charged and hooked up to
the electrical system.
4. Remove the transit bars (if so equipped).
5. Press and hold the IN/OUT switch in the OUT position until the room is fully
extended and stops moving.
6. Release the switch, which will lock the room into position. If the slideout switch is
held after the room is fully extended, the control will sense that the room has stopped
and will shut the motor off after a few seconds.
Retracting the room
1. Verify the battery is fully charged and hooked up to the electrical system.
2. Press and hold the IN/OUT switch in the IN position until the room is fully retracted
and stops moving.
CAUTION
WARNING
5-8
JAYCO TOWABLE