Cornelius ENDURO-150 6 VALVE Operator's Manual
  1. Manuals
  2. Brands
  3. Cornelius Manuals
  4. Beverage Dispenser
  5. ENDURO-150 6 VALVE
  6. Operator's manual
Cornelius ENDURO-150 6 VALVE Operator's Manual

Cornelius ENDURO-150 6 VALVE Operator's Manual

Ice/beverage dispenser
Hide thumbs Also See for ENDURO-150 6 VALVE:
Table of Contents

Advertisement

Quick Links

Download this manual
OPERATOR S MANUAL
ICE/BEVERAGE DISPENSER
MODELS: ENDURO-150 6 VALVE
Release Date: February 25, 2004
Publication Number: 92096OPR
Revision Date: March 27, 2014
Revision: D
Visit the Cornelius web site at www.cornelius.com for all your Literature needs.

Advertisement

Table of Contents
loading

Related Manuals for Cornelius ENDURO-150 6 VALVE

Summary of Contents for Cornelius ENDURO-150 6 VALVE

  • Page 1 OPERATOR S MANUAL ICE/BEVERAGE DISPENSER MODELS: ENDURO-150 6 VALVE Release Date: February 25, 2004 Publication Number: 92096OPR Revision Date: March 27, 2014 Revision: D Visit the Cornelius web site at www.cornelius.com for all your Literature needs.

  • Page 2: Contact Information

    Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal...

  • Page 3: Table Of Contents

    TABLE OF CONTENTS S S a a f f e e t t y y I I n n s s t t r r u u c c t t i i o o n n s s ......................... . 1 1 Read And Follow All Safety Instructions .

  • Page 5: Read And Follow All Safety Instructions

    S S E E R R I I O O U U S S I I N N J J U U R R Y Y , , D D E E A A T T H H O O R R E E Q Q U U I I P P M M E E N N T T D D A A M M A A G G E E . . © 2004-2014, Cornelius Inc.

  • Page 6: Safety Precautions

    NOTE: Note:Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the additional weight the counter will need to support to ensure a safe installation. Publication Number: 92096OPR - 2 - © 2004-2014, Cornelius Inc.

  • Page 7: S S T T A A R R T T - - U U P P A A N N D D O O P P E E R R A A T T I I N N G G I I N N S S T T R R U U C C T T I I O O N N S

    NOTE: This appliance is not intended for use by personnel (including children) with reduced physical, sensory or mental capabilities or lack of experience and knowledge, unless given supervision or instruction concerning use of the appliance by a person responsible for safety. © 2004-2014, Cornelius Inc. - 3 - Publication Number: 92096OPR...

  • Page 8: Daily Cleaning

    Ice/Beverage Dispenser Operator s Manual CLEANING AND MAINTENANCE INSTRUCTIONS These instructions are used on all Cornelius ice drink dispensers. Some models may have additional cleaning requirements. Those models will have addition procedures listed later in the manual. WARNING: Disconnect power to the unit before cleaning or servicing following all lock out / tag out procedures established by the user.

  • Page 9: Cleaning Interior Surfaces (Monthly Cleaning)

    6. Install and properly position the access covers on the cold plate. 7. Install the splash panel in the reverse order it was removed. 8. Rinse cold plate surface by pouring potable water through hopper openings. © 2004-2014, Cornelius Inc. - 5 - Publication Number: 92096OPR...

  • Page 10: Dispensing Valves: ( Daily Cleaning)

    9. Remove the sanitizing fittings from the B I B disconnects and connect the disconnects to the appropriate B I B container. Operate the valves until all sanitizer has been flushed from the system and syrup is flow- ing freely. Publication Number: 92096OPR - 6 - © 2004-2014, Cornelius Inc.

  • Page 11: Replenishing Co2 Supply (As Required)

    (back-seating the valve prevents gas leakage around the valve shaft). Check CO connections for leaks. Tighten any loose connections. 7. Check CO2 connections for leaks. Tighten any loose connections. © 2004-2014, Cornelius Inc. - 7 - Publication Number: 92096OPR...

  • Page 12: Blown Fuse Or Circuit Breaker

    BEVERAGES NOT SWEET ENOUGH. B. Faucet brix requires adjusting A. Unit standing with no ice in hopper -- no ice incold BEVERAGES NOT COLD (UNITS WITH BUILT-IN plate cabinet. COLD PLATE). Publication Number: 92096OPR - 8 - © 2004-2014, Cornelius Inc.

  • Page 13: Flavor Syrups Do Not Dispense

    FLAVOR DISPENSES MORE THAN .5 OZ C. PC board defective D. Defective flow control. Contact your local syrup or beverage equipment distributor for additional information and troubleshooting of beverage system. © 2004-2014, Cornelius Inc. - 9 - Publication Number: 92096OPR...
  • Page 14 Ice/Beverage Dispenser Operator s Manual Publication Number: 92096OPR - 10 - © 2004-2014, Cornelius Inc.
  • Page 16 Cornelius Inc. www.cornelius.com...

Table of Contents