Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Cornelius Enduro-200/250
Summary of Contents for Cornelius Enduro-200/250
-
Page 1: Installation Manual
INSTALLATION MANUAL ICE/BEVERAGE DISPENSER MODEL: ENDURO-200/250 Release Date: March 24, 2004 Publication Number: 92181INS Revision Date: August 3, 2010 Revision: F Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs. -
Page 2: Contact Information
Commercial Warranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than normal and proper use and normal... -
Page 3: Table Of Contents
TABLE OF CONTENTS Safety Instructions..............1 Read and Follow ALL Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. Publication Number: 92181INS AFETY NSTRUCTIONS Recognize Safety Alerts - 1 - © 2006-2010, IMI Cornelius Inc. -
Page 5: Safety Precautions
NOTE: Many units incorporate the use of additional equipment such as icemakers. When any addition equipment is used you must check with the equipment manufacturer to determine the addi- tional weight the counter will need to support to ensure a safe installation. © 2006-2010, IMI Cornelius Inc. Ice/Beverage Dispenser installation Manual ARNING... -
Page 6: Description
Yes, On BC Model Only 120/1/60, 3.5 Amps 220--240/1/50--60, 2.0 Amps 30 in. Wide X 30-11/16 in. Deep X 39-5/8 in. High 30 in. Wide X 23-1/16 in. Deep X 39-5/8 in. High - 3 - ED250 (Ice Only) © 2006-2010, IMI Cornelius Inc. -
Page 7: Installation Instructions
9. The unit has to be placed in a horizontal position. 10. If the supply cord is damaged, it must be replaced by the manufacturer, it’s service agent or similarly qualified person in order to avoid a hazard. © 2006-2010, IMI Cornelius Inc. Ice/Beverage Dispenser installation Manual must pitch continuously downward and contain no “traps”... -
Page 8: Adjust Water -To-Syrup Ratio
CAUTION: Disconnect power to dispenser before installing, removing or adjusting restrictor. See Safety Section of this manual. Publication Number: 92181INS Separator Water-To-Syrup Ratio Cup Figure 1.Ratio Cup Figure 2. Gate Restrictor Plate - 5 - © 2006-2010, IMI Cornelius Inc. -
Page 9: Adjustment
NOTE: Recommended counter opening size 9” X 12” for utilities and beverage tubing. Opening can be located anywhere within the shaded area. Figure 3. Mounting Template © 2006-2010, IMI Cornelius Inc. - 6 - Publication Number: 92181INS... - Page 10 Ice/Beverage Dispenser installation Manual Figure 4. Drip Tray Drain Assembly Publication Number: 92181INS - 7 - © 2006-2010, IMI Cornelius Inc.
- Page 11 Ice/Beverage Dispenser installation Manual Figure 5. Flow Diagram (Unit with Six Faucets) © 2006-2010, IMI Cornelius Inc. - 8 - Publication Number: 92181INS...
- Page 12 Ice/Beverage Dispenser installation Manual Figure 6. Flow Diagram (Unit with Eight Faucets) Publication Number: 92181INS - 9 - © 2006-2010, IMI Cornelius Inc.
- Page 13 Ice/Beverage Dispenser installation Manual Figure 7. Flow Diagram (Unit with Ten Faucets) © 2006-2010, IMI Cornelius Inc. - 10 - Publication Number: 92181INS...
- Page 14 Ice/Beverage Dispenser installation Manual Figure 8. Flow Diagram (“B” Unit with Eight Beverage Faucets) Publication Number: 92181INS - 11 - © 2006-2010, IMI Cornelius Inc.
- Page 15 Ice/Beverage Dispenser installation Manual Figure 9. Wiring Diagram (115 Volts Unit) © 2006-2010, IMI Cornelius Inc. - 12 - Publication Number: 92181INS...
- Page 16 Ice/Beverage Dispenser installation Manual Figure 10. Schematic (115 Volt Unit) Publication Number: 92181INS - 13 - © 2006-2010, IMI Cornelius Inc.
- Page 17 Ice/Beverage Dispenser installation Manual Figure 11. Wiring Diagram (220-240 Volt Unit) © 2006-2010, IMI Cornelius Inc. - 14 - Publication Number: 92181INS...
- Page 18 Ice/Beverage Dispenser installation Manual Figure 12. Schematic (220-240 Volt Unit) Publication Number: 92181INS - 15 - © 2006-2010, IMI Cornelius Inc.
-
Page 19: Troubleshooting
BEVERAGES TOO SWEET. BEVERAGE NOT SWEET ENOUGH. BEVERAGES NOT COLD (UNITS WITH BUILT-IN COLD PLATE). FLAVOR SYRUPS DO NOT DISPENSE. © 2006-2010, IMI Cornelius Inc. Ice/Beverage Dispenser installation Manual system, stop dispensing, shut off the Probable Cause Short circuit in wiring. -
Page 20: Flavor Dispenses For More Than 1 Sec
Dip switch settings on control board incorrect. PC board defective. C. Defective flow control. Dip switch settings on control board incorrect. Flow control incorrectly set. C. PC board defective. Defective flow control. - 17 - © 2006-2010, IMI Cornelius Inc. - Page 22 IMI Cornelius Inc. www.cornelius.com...
Need help?
Do you have a question about the Enduro-200/250 and is the answer not in the manual?
Questions and answers