Champion 75537i Owner's Manual & Operating Instructions
3100 max watts / 2800 rated watts wireless remote, electric start portable inverter generator
Hide thumbs
Also See for 75537i:
- Owners manual and operation instructions (33 pages) ,
- Manual (11 pages) ,
- Technical bulletin (9 pages)
Table of Contents
Advertisement
3100 Max Watts / 2800 Rated Watts
Wireless Remote, Electric Start
PORTABLE INVERTER GENERATOR
SAVE THESE INSTRUCTIONS
Important Safety Instructions
are included in this manual.
OWNER'S MANUAL & OPERATING INSTRUCTIONS
MODEL NUMBER
75537i
MADE IN CHINA
REV 75537i-20140703
12039 Smith Ave.
Santa Fe Springs CA 90670 USA
1-877-338-0999
www.championpowerequipment.com
Advertisement
Table of Contents
Related Manuals for Champion 75537i
Summary of Contents for Champion 75537i
- Page 1 3100 Max Watts / 2800 Rated Watts Wireless Remote, Electric Start PORTABLE INVERTER GENERATOR MODEL NUMBER 75537i 12039 Smith Ave. SAVE THESE INSTRUCTIONS Santa Fe Springs CA 90670 USA Important Safety Instructions 1-877-338-0999 MADE IN CHINA are included in this manual. REV 75537i-20140703 www.championpowerequipment.com...
- Page 2 FCC Statement This device complies with Part 15 of the FCC Rules. accordance with the instructions, may cause harmful Operation is subject to the following two conditions: interference to radio communications. However, there (1) This device may not cause harmful interference. is no guarantee that interference will not occur in a (2) This device must accept any interference particular installation.
-
Page 3: Table Of Contents
75537i 3100 Max Watts / 2800 Rated Watts Wireless Remote, Electric Start PORTABLE INVERTER GENERATOR TABLE OF CONTENTS Spark Plugs ..... . . -
Page 4: Introduction
ENGLISH INTRODUCTION Introduction Accessories Congratulations on your purchase of a Champion Power Champion Power Equipment manufactures and sells Equipment inverter generator. CPE designs and builds accessories designed to help you get the most from generators to strict specifications. With proper use and your purchase. -
Page 5: Manual Conventions
Please call our help line at 1-877-338-0999 situation which, if not avoided, could result in death or serious injury. CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. REV 75537i-20140703... -
Page 6: Safety Rules
This product contains a button battery. If loss of power would cause you or anyone in your swallowed, it could cause severe injury or death in household to experience a medical emergency. just 2 hours. Seek medical attention immediately. REV 75537i-20140703... - Page 7 – Electrical output is lost – Equipment sparks, smokes or emits flames A spark arrestor may be required. The operator – Equipment vibrates excessively should contact local fire agencies for laws or regulations relating to fire prevention requirements. REV 75537i-20140703...
-
Page 8: Controls And Features
Never Flat Wheels to lift or carry the unit. Battery Access Cover Parts Included Your 75537i gasoline powered generator ships with the following parts: – Automotive style USB adapter (2.1A and 1A ports) ..... . -
Page 9: Power Panel
*Warning: Do not operate a device while it is plugged into the 12V DC outlet. Prolonged exposure to engine exhaust can cause serious injury or death. While charging a device do no place on the exhaust side of the generator. Extreme heat caused by exhaust can damage the device, and cause a potential fire hazard. REV 75537i-20140703... -
Page 10: Wireless Remote Control
(6) times. The RCM controls the Auto Choke during each attempt to start. If the generator does not start, call Champion Customer Care team for assistance at 1-877-338-0999. To stop the generator by Remote Control, press the “STOP”... -
Page 11: Assembly
(-) battery terminal. NOTE If the battery cables are not visible once the battery maintenance cover has been removed, please note that cables may be tucked up above the battery, REV 75537i-20140703 not in plain view. - Page 12 After the 5 hour break-in period, change the oil. NOTE Synthetic oil may be used after the 5 hour initial break-in period. Using synthetic oil does no increase the recommended oil change interval. REV 75537i-20140703...
-
Page 13: Add Fuel
We strongly recommend that you consult with a qualified electrician to ensure compliance with local electrical codes. REV 75537i-20140703... -
Page 14: Operation
When the battery switch is in the “ON” position, the switch will light up if the battery is sending out a charge. If the switch does not light up while in the “ON” position, check that the battery connection is still good. REV 75537i-20140703... -
Page 15: Electric And Recoil Start
Push the Choke button in to the “Choke” position. Turn the engine switch to the “On” position. ELECTRIC START: Press and hold the ignition switch to the “START” position. Release as the engine begins to roll over. If the engine fails to start REV 75537i-20140703... -
Page 16: Manual Choke Start
Turn the fuel valve to the “ON” position. Turn the engine switch to the “ON” position. Pull the recoil rope until resistance is felt, then pull rapidly. As the engine starts to roll over, move the choke lever to the “RUN” position. REV 75537i-20140703... -
Page 17: Connecting Electrical Loads
Extreme heat caused by exhaust can Important: Always ensure that the Fuel Valve and the damage the device, and cause a potential fire hazard. Engine Switch and battery switch are in the “OFF” position when the engine is not in use. REV 75537i-20140703... -
Page 18: Do Not Overload Generator
To alleviate high altitude issues other than the natural starting watts necessary for your purposes. Select the electrical devices you plan on running at power loss, Champion Power Equipment can provide a the same time. high altitude carburetor main jet. The alternative main Total the running watts of these items. -
Page 19: Wireless Set Button
NOTE Only two remote controls can be in sync with one generator at a time. NOTE Changing a remote control battery may not require the user to reset the remote control. REV 75537i-20140703... -
Page 20: Maintenance And Storage
Tilt the generator on its side and allow the oil to drain completely. Replace the 12 mm drain bolt. Add up to 0.6 qt. (0.6 L) of standard engine oil and replace oil fi ll cap/dipstick. DO NOT OVERFILL. REV 75537i-20140703... -
Page 21: Air Filter
Service your generator more frequently when operating CAUTION in adverse conditions. Contact our help line at 1-877-338-0999 to locate the nearest Champion Power Equipment certified service DO NOT spray generator with water. dealer for your generator or engine maintenance needs. Water can contaminate the fuel system. -
Page 22: Charge The Battery
DO NOT use a garden hose to clean the generator. Valve and the Battery Switch are set in the the Water can enter the generator through the cooling the OFF position and the battery leads have been slots and damage the generator windings. disconnected from the battery. REV 75537i-20140703... -
Page 23: Specifications
....1.6 gal. (6 L) Your Champion Power Equipment product is designed – Gross Weight .... -
Page 24: Parts Diagram
75537i ENGLISH SPECIFICATIONS Parts Diagram REV 75537i-20140703... -
Page 25: Parts List
5.1110.006 Receptacle (Battery Charger) 83.201600.02 Supporter, Left 9.2600.000 Remote Control 83.201600.01 Supporter, Right 9.1700.003 Automotive style USB adapter (2.1A and 1A ports) 83.201200.01 Motor Mount 9.1600.012 Cables, 12V, 2m 83.200607.01 Plug 9.1700.004 Smart Charger 1.6182.06 Lock Nut M6 REV 75537i-20140703... -
Page 26: Engine Parts Diagram
75537i ENGLISH SPECIFICATIONS Engine Parts Diagram REV 75537i-20140703... -
Page 27: Engine Parts List
83.131017.01 Standard Main Jet 83.125200.01 Relay, Starter 83.131017.01.01 Altitude Main Jet 1.5789.0615 Flange Bolt M6×15 83.061000.01 Recoil Assembly 83.030008.01 Gasket, Crankcase Cover 83.091000.01 Air Cleaner Assembly 1.9074.4.0510 Screw M5×10 83.021000.01 Cylinder Head Cover Assembly 83.080014.01.01 Air Guide Board REV 75537i-20140703... -
Page 28: Wiring Diagram
75537i ENGLISH SPECIFICATIONS Wiring Diagram REV 75537i-20140703... -
Page 29: Troubleshooting
Review load and adjust. See “Power Management” Faulty cords or device Check for damaged, bare or frayed wires. Replace defective device For further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment.com REV 75537i-20140703... -
Page 30: Warranty
Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc. - Page 31 The United States Environment Protection Agency (U.S. EPA.) and the California Air Resources Board (CARB) Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with both the U.S. EPA and state of California Air Resources Board (CARB) emission regulations.
- Page 32 EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICABILITY: This warranty shall apply to 1995 and later model year California small off-road engines (for other states, 1997 and later model year engines). The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
- Page 33 You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.