Page 1
3100 Max Watts / 2800 Rated Watts PORTABLE INVERTER GENERATOR MODEL NUMBER 75551i 10006 Santa Fe Springs Road sAVE ThEsE INsTRuCTIONs Santa Fe Springs CA 90670 USA Important Safety Instructions 1-877-338-0999 MADE IN CHINA are included in this manual. REV 75551i-20130131 www.championpowerequipment.com...
Page 2
Have questions or need assistance? Do not return this product to the store! WE ARE HERE TO HELP! Visit our website: www.championpowerequipment.com for more info: • Product Info & Updates • Tech Bulletins • Frequently Asked Questions • Product Registration –...
ENGLISH INTRODuCTION Introduction Accessories Congratulations on your purchase of a Champion Power Champion Power Equipment manufactures and sells Equipment inverter generator . CPE designs and builds accessories designed to help you get the most from generators to strict specifications . With proper use and your purchase .
. Please call our help line at 1-877-338-0999 situation which, if not avoided, could result in death or serious injury . CAuTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury . REV 75551i-20130131...
Inform your electricity provider immediately if you or anyone in your household depends on electrical equipment to live . Inform your electrical provider immediately if a loss of power would cause you or anyone in your household to experience a medical emergency . REV 75551i-20130131...
Page 7
– Electrical output is lost – Equipment sparks, smokes or emits flames A spark arrestor may be required . The operator – Equipment vibrates excessively should contact local fire agencies for laws or regulations relating to fire prevention requirements . REV 75551i-20130131...
Carrying Handle Muffler Parts Included Your 75551i Gasoline Powered Generator ships with the following parts: – 12V DC Battery Cables 2 m (6 .6 ft .) . . . . . . . . . .
*Warning: Do not operate a device while it is plugged into the 12V DC outlet . Prolonged exposure to engine exhaust can cause serious injury or death . While charging a device do no place on the exhaust side of the generator . Extreme heat caused by exhaust can damage the device, and cause a potential fire hazard . REV 75551i-20130131...
1 . Place the generator on a flat, level surface . 2 . Loosen the cover screws and remove the NOTE maintenance cover . The generator rotor has a sealed, pre-lubricated ball bearing that requires no additional lubrication for the life of the bearing . REV 75551i-20130131...
. minimum) copper wire between the generator ground terminal and a copper rod driven into the ground . We strongly recommend that you consult with a qualified electrician to ensure compliance with local electrical codes . REV 75551i-20130131...
During operation the muffler and exhaust fumes produced will become hot . If adequate cooling and breathing space are not supplied, or if the generator is blocked or contained, temperatures can become extremely heated and may lead to fire . REV 75551i-20130131...
. Extreme heat caused by exhaust can damage the device, and cause a potential fire hazard . For periods of high electrical load or momentary fluctuations, the Economy Control Switch should be turned OFF . REV 75551i-20130131...
If the engine will not be used for a period of two (2) recover the power, shut down the engine, wait until the weeks or longer, please see the storage section for proper light turns off and restart the generator . engine and fuel storage . REV 75551i-20130131...
Remove the 12 mm drain bolt . 9 . Attach the spark plug cap to the plug . Tilt the generator on its side and allow the oil to 10 . Reinstall the spark plug access cap, and drain completely . maintenance cover . REV 75551i-20130131...
. Contact our help line at 1-877-338-0999 to locate the DO NOT spray engine with water . nearest Champion Power Equipment certified service dealer for your generator or engine maintenance needs . Water can contaminate the fuel system .
– When storing the generator for short or extended periods of time make sure that the Engine Switch and the Fuel Valve are set in the OFF position . REV 75551i-20130131...
10% by volume . Use 10W-30 automotive oil . Oil capacity is 0 .6 L (0 .63 qt .) . DO NOT OVERFILL Please reference the following chart for recommended oil types for use in the generator . REV 75551i-20130131...
Review load and adjust . See “Power Management” Faulty cords or device Check for damaged, bare or frayed wires . Replace defective device for further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment .com REV 75551i-20130131...
. Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc .
Page 26
Champion Power Equipment, Inc (CPE), Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with Environment Canada (EC) emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: CPE is pleased to explain the Emission Control Systems Warranty on your 2013 small off-road engine.
Page 27
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. Emission Control System Warranty (ECS Warranty): 1. APPLICABILITY: The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
Page 28
You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.