Advertisement
Table of Contents
- 1 Manual Conventions
- 2 Safety Rules
- 3 Operation
- 4 Fuel Selector Switch
- 5 Stopping the Engine
- 6 Connecting Electrical Loads
- 7 Do Not Overload Generator
- 8 Maintenance and Storage
- 9 Engine Maintenance
- 10 Generator Maintenance
- 11 Troubleshooting
- 12 Generator Battery
- 13 Specifications
- 14 Technical Diagrams
- Download this manual
Advertisement
Table of Contents
Related Manuals for Champion CPG7500E2-DF-EU
Summary of Contents for Champion CPG7500E2-DF-EU
- Page 1 OWNER’S MANUAL & OPERATING INSTRUCTIONS Frame Type Electric Start DUAL FUEL GENERATOR U.S. Patent No. D710,802 This manual covers the following models: 3500 E2 DF (EU) / 7500 E2 DF (EU) SAVE THESE INSTRUCTIONS Important Safety Instructions are included in this manual.
-
Page 2: Manual Conventions
WARNING indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury. Champion Power Equipment Support CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor Model Number or moderate injury. -
Page 3: Safety Rules
SAFETy RULES SAFETy RULES WARNING DANGER WARNING CAUTION Rapid retraction of the starter cord will pull hand and Generator produces powerful voltage. Read this manual thoroughly before operating your Improper treatment or use of the generator can arm towards the engine faster than you can let go. generator. - Page 4 SAFETy RULES ASSEMBLy Fuel Safety Install the Support Leg When adding or removing Petrol: Your generator requires some assembly. This unit ships from our factory without oil. It must be properly serviced Turn the generator off and let it cool for at least two 1.
- Page 5 ASSEMBLy ASSEMBLy Add Engine Oil Add Engine Oil Cont’d. Add Fuel (Petrol) Add Fuel (Petrol) Cont’d. 1. Use clean, fresh, regular unleaded fuel with a CAUTION NOTE WARNING minimum octane rating of 85 and an ethanol content Check oil often during the break-in period. Refer to the of less than 10% by volume.
- Page 6 ASSEMBLy ASSEMBLy Connecting Liquid Petroleum Gas (LPG) Cylinder Connecting LPG Cylinder Cont’d. Generator Location Grounding 1. Make sure the fuel valve on the generator is in the off Never operate the generator inside any building! (See The generator system ground connects the frame to the CAUTION position.
-
Page 7: Operation
OPERATION OPERATION Starting the Engine Cont’d. Fuel Selector Switch Starting the Engine in ambient > 15°C (59°F) 1. Make certain the generator is on a flat, level surface. The fuel selector switch on the front panel of the Petrol NOTE 2. -
Page 8: Stopping The Engine
OPERATION OPERATION Starting the Engine Cont’d. Stopping the Engine Cont’d. Do Not Overload Generator Capacity NOTE NOTE Follow these simple steps to calculate the running and Observing frost on LPG containers and regulators When turning off the generator after LPG operation, make starting watts necessary for your purposes. -
Page 9: Maintenance And Storage
To prevent accidental starting, remove and ground spark *To be performed by knowledgeable, experienced owners or Adjustments 0.028 - 0.031 in. Champion Power Equipment certified dealers. plug wire before performing any service. The air-fuel mixture is not adjustable. Tampering with Generator Maintenance... -
Page 10: Troubleshooting
MAINTENANCE AND STORAGE TROUBLESHOOTING Storage Generator Battery Problem Cause Solution The generator should be started at least once every 14 This product is equipped with an automatic battery No fuel Add fuel days and allowed to run for at least 20 minutes. For charging circuit. -
Page 11: Specifications
SPECIFICATIONS SPECIFICATIONS SPECIFICATIONS CPG3500E2-DF-EU SPECIFICATIONS CPG7500E2-DF-EU Gasoline Starting Watts 2800W Gasoline Starting Watts 7000W Gasoline Running Watts 2500W Gasoline Running Watts 6000W Propane Starting Watts 2600W Propane Starting Watts 5500W Propane Running Watts 2300W Propane Running Watts 5000W Gasoline Starting Amps Gasoline Starting Amps 12.73A... -
Page 12: Technical Diagrams
TECHNICAL DIAGRAMS TECHNICAL DIAGRAMS 3500 E2 (EU) PARTS DIAGRAM 3500 E2 (EU) PARTS LIST... - Page 13 TECHNICAL DIAGRAMS TECHNICAL DIAGRAMS 3500 E2 (EU) PARTS DIAGRAM 3500 E2 (EU) PARTS LIST...
- Page 14 CPG7500E2-DF-EU TECHNICAL DIAGRAMS TECHNICAL DIAGRAMS CPG7500E2-DF-EU 7500 E2 (EU) PARTS DIAGRAM 7500 E2 (EU) PARTS LIST...
- Page 15 CPG7500E2-DF-EU TECHNICAL DIAGRAMS TECHNICAL DIAGRAMS CPG7500E2-DF-EU 7500 E2 (EU) PARTS DIAGRAM 7500 E2 (EU) PARTS LIST...
- Page 16 TECHNICAL DIAGRAMS TECHNICAL DIAGRAMS CPG7500E2-DF-EU 3500 E2 (EU) WIRING DIAGRAM 7500 E2 (EU) WIRING DIAGRAM...