Frame type electric start.
dual fuel generator (17 pages)
Summary of Contents for Champion 73535i
Page 1
PORTABLE INVERTER GENERATOR MODEL NUMBER 73535i US Patent # D656897, 8391012 10006 Santa Fe Springs Road SAVE ThESE INSTRUCTIONS Santa Fe Springs CA 90670 USA Important Safety Instructions 1-877-338-0999 MADE IN CHINA are included in this manual. REV 73535i-20130307 www.championpowerequipment.com...
Page 2
AN IMPORTANT MESSAGE ABOUT TEMPERATURE: Your Champion Power Equipment product is designed and rated for continuous operation at ambient temperatures up to 40°C (104°F). When your product is needed your product may be operated at temperatures ranging from -15°C (5°F) to 50°C (122°F) for short periods.
ENGLISH INTRODUCTION Introduction Accessories Congratulations on your purchase of a Champion Power Champion Power Equipment manufactures and sells Equipment inverter generator. CPE designs and builds accessories designed to help you get the most from your generators to strict specifications. With proper use and purchase.
Please call our help line at 1-877-338-0999 situation which, if not avoided, could result in death or serious injury. CAUTION CAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or moderate injury. REV 73535i-20130307...
Inform your electricity provider immediately if you or anyone in your household depends on electrical equipment to live. Inform your electrical provider immediately if a loss of power would cause you or anyone in your household to experience a medical emergency. REV 73535i-20130307...
Page 7
– Electrical output is lost – Equipment sparks, smokes or emits flames A spark arrestor may be required. The operator – Equipment vibrates excessively should contact local fire agencies for laws or regulations relating to fire prevention requirements. REV 73535i-20130307...
Fuel Lever Vent – Turn this valve to the “On” Maintenance Cover – Oil filler, Air filter, and position to supply air to the tank. Carburetor access. Fuel Cap – Remove to add fuel. Muffler Recoil Starter – Used to start the engine. REV 73535i-20130307...
(12) Ground Terminal – Consult an electrician for local grounding regulations. * These outlets are used for connecting two Champion model 73535i generators for parallel operation. A Champion model 73500i parallel kit (optional equipment) is required for parallel operation.
NOTE Check oil often during the break-in period. Refer to the Maintenance section for recommended service intervals. NOTE The generator rotor has a sealed, pre-lubricated ball bearing that requires no additional lubrication for the life of the bearing. REV 73535i-20130307...
During operation the muffler and exhaust fumes produced will become hot. If adequate cooling and breathing space are not supplied, or if the generator is blocked or contained, temperatures can become extremely heated and may lead to fire. REV 73535i-20130307...
When the economy switch is off, the engine runs at normal speed continuously. WARNING For periods of high electrical load or momentary fluctuations, the Economy Control Switch should be turned OFF. REV 73535i-20130307...
Parallel Operation NOTE Two Champion model 73535i generators can be If the engine will not be used for a period of two (2) weeks operated in parallel to increase the total available or longer, please see the storage section for proper engine electrical power to 3000 watts.
9. Attach the spark plug cap to the plug. Reinstall the maintenance cover and tighten the 10. Reinstall the spark plug access cap, and cover screws. maintenance cover. Dispose of used oil at an approved waste management facility. REV 73535i-20130307...
The air-fuel mixture is not adjustable. Tampering with the governor can damage your generator and your electrical devices and will void your warranty. CPE recommends that you contact our service line at 1-877-338-0999 for all other service and/or adjustment needs. REV 73535i-20130307...
Contact our help line at 1-877-338-0999 to locate the Add a properly formulated fuel stabilizer to the tank. nearest Champion Power Equipment certified service Be sure all appliances are disconnected from the dealer for your generator or engine maintenance needs.
Groove Jacket 81.200103.00 Connect Port 81.210001.00 81.220001.00 Protector, Control Unit Bolt And Washer Assembly 1.9074.4.0210.3 81.220002.00 Mount Rubber, Control Unit M2×10 81.200602.00 Mounting Rubber, End Cover 1.9074.4.0414.3 Bolt And Washer Assembly 81.200603.00 Mounting Rubber, Engine M4×14 2.05.050 Clamp, Wire REV 73535i-20130307...
Review load and adjust. See “Power Management” Faulty cords or device Check for damaged, bare or frayed wires. Replace defective device for further technical support: Technical Service Mon – Fri 8:30 AM – 5:00 PM (PST/PDT) Toll Free: 1-877-338-0999 tech@championpowerequipment.com REV 73535i-20130307...
Warranty Qualifications Other Exclusions Champion Power Equipment (CPE) will register this This warranty excludes: warranty upon receipt of your Warranty Registration Card – Cosmetic defects such as paint, decals, etc.
Page 26
Champion Power Equipment, Inc (CPE), Emission Control System Warranty Your Champion Power Equipment (CPE) engine complies with Environment Canada (EC) emission regulations. YOUR WARRANTY RIGHTS AND OBLIGATIONS: CPE is pleased to explain the Emission Control Systems Warranty on your 2013 small off-road engine.
Page 27
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System Warranty Coverage. Emission Control System Warranty (ECS Warranty): 1. APPLICABILITY: The ECS Warranty Period shall begin on the date the new engine or equipment is delivered to its original, end-use purchaser, and shall continue for 24 consecutive months thereafter.
Page 28
You must take your CPE engine or the product on which it is installed, along with your warranty registration card or other proof of original purchase date, at your expense, to any Champion Power Equipment dealer who is authorized by Champion Power Equipment, Inc. to sell and service that CPE product during his normal business hours.
Need help?
Do you have a question about the 73535i and is the answer not in the manual?
Questions and answers