Table of Contents
Advertisement
Quick Links
INSTALLATION, OPERATION AND MAINTENANCE MANUAL
Please read carefully before proceeding with installation. Your failure to follow any attached instructions
Refer to enclosed warranty for operating parameters to ensure proper use with your water supply.
Premier, Inc.
Phone: 800-752-5582
P/N 199484
or operating parameters may lead to the product's failure.
Save manual for future reference
Model: EZ-RO 4
8716 W Ludlow Drive Suite #1
www.premierH2o.com
Warning
Page 1
Peoria, AZ 85381
Fax: 623-866-5666
Manual Edition: 11/10/10
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Premier EZ-RO 4
Summary of Contents for Premier EZ-RO 4
- Page 1 Please read carefully before proceeding with installation. Your failure to follow any attached instructions or operating parameters may lead to the product’s failure. Save manual for future reference Model: EZ-RO 4 Refer to enclosed warranty for operating parameters to ensure proper use with your water supply. Premier, Inc.
-
Page 2: System Overview
Thank you for your purchase of a state of the art Premier Reverse Osmosis (RO) water treatment system. Water quality concerns are becoming more of a focus for the public. You may have heard about contaminants in the drinking water such as Arsenic, Perchlorate, Chromium, Cryptosporidium or Giardia. -
Page 3: Table Of Contents
With proper installation and maintenance, this system will provide you with high quality water for years to come. All of Premier’s water enhancement products are rigorously tested by independent laboratories for safety and reliability. If you have any questions or concerns, please contact our customer service department at 1-800-752- 5582 (outside USA 480-675-7995) or refer to our on-line troubleshooting guide at www.premierH2o.com. -
Page 4: Operational Parameters
Premier supplies speciality filters (part number 107008) that can be used if copper tubing follows the Reverse Osmosis unit. Be sure to follow any state or local regulations during installation. -
Page 5: Drill A Hole For The Faucet In A Porcelain Sink
RO faucet. (If you are already using it for a sprayer or soap dispenser, see step 1) Porcelain sinks are extremely hard and can crack or chip easily. Use extreme caution when drilling. Premier accepts no responsibility for damage resulting from the installation of faucet. -
Page 6: Faucet Installation
Faucet Installation (Actual RO Faucet may vary) Feed both the red and black tubing through the pre drilled hole in the sink/counter until faucet Step 6 is seated. Step 7 Locate one of the two 1/4” blue tubes in the box. In the faucet parts bag locate a compression nut, plastic ferrule sleeve and a plastic tube insert. -
Page 7: Adapt-A-Valve Installation
Installation of the drain saddle near a garbage disposal may cause the drain line to plug. If no other installation of drain line is available, Premier offers drain line installation kit (part number 164020) that can be used with garbage disposals. -
Page 8: Drill Hole And Connect 3/8" Black Tube From Faucet To The Drain Saddle
Drill Hole and Connect 3/8” Black Tube from Faucet to the Drain IMPORTANT: The black 3/8” drain tube must be as SHORT and STRAIGHT as possible to the drain saddle, making a downward slope from faucet to drain saddle to allow for proper drainage. -
Page 9: Connection On The Back Of The Reverse Osmosis System
Connections on the back of the Reverse Osmosis System * Remove Red protective plugs before tube installation! NOTE 1/4” Blue Tube Connection - 1/4” Green Tube Connection - to RO Faucet to Adapt-a-Valve 1/4” Blue Tube Connection - to RO TANK Green Tube Connection Step 16 Locate the 1/4”... -
Page 10: Red Tube Connection (From Ro Faucet To The Ro Module)
Red Tube Connection (From RO FAUCET To The RO Module) Step 20 The RO Membrane (Green Label) has a 1/4” quick connect fitting located on the bottom of the cartridge. Remove the red protective cap and insert the 1/4” quick connect elbow stem located on the end of the 1/4”... -
Page 11: Start-Up Instructions
Don’t Forget To Register! Register by mail, phone, fax or internet. Premier uses this information only to provide a filter change reminder notice. Pre-filters should be changed every 6 months and the Post Carbon filter annually. You may register your warranty via our web site at www.premierH2o.com or call 1-800-752-5582 (within USA only) / FAX#: 623-866-5666. -
Page 12: Changing The Filter Cartridges
75%. A water sample may be sent to Premier for a free diagnosis of your membranes performance. To send a water sample, use 2 clean containers and fill 1/2 cup of tap water in one container and 1/2 cup of RO water in 2nd container. -
Page 13: Annual Sanitization
Annual Sanitization Note: Sanitization procedure should be performed before a filter change. Step 1 Turn off the water supply to your RO system by turning the “T” on the adapt-a-valve clockwise 1/4” turn and open the RO faucet to drain the storage tank. -
Page 14: Check Air Pressure In The Tank
Check Air Pressure in the Tank Check air pressure only when tank is empty of water! Important: Check air pressure in the storage tank when you notice a decrease in available water from the RO system. Air can be added with a bicycle pump using the schrader valve that is located on the lower side of the tank behind a blue plastic cap. -
Page 15: Trouble Shooting
1. Low/Slow Production Low Water Pressure Assure a minimum of 40 psi incoming water pressure. Premier sells a booster pump if home water pressure is low. Make sure water supply is turned on and Adapta Valve is all the way open. -
Page 16: Performance Data Sheet
2. This system is acceptable for treatment of influent concentrations of no more than 27 mg/L nitrate and 3 mg/L nitrite in combination measured as N and is certified for nitrite/nitrate reduction only for water supplies with a pressure of 280 kPa (40 psig) or greater. If your water supply is under 40 psi Premier recomends the use of a RO booster pump for proper operation. -
Page 17: Arsenic Fact Sheet
This Premier reverse osmosis system is designed to remove up to 98% of pentavalent arsenic. It will not convert trivalent arsenic to pentavalent arsenic. Under laboratory standard testing conditions, this system reduced 0.30 mg/L (ppm) pentavalent arsenic... -
Page 18: Nitrate-Nitrite Test Instruction
Nitrate / Nitrite Test Instruction Page 18... -
Page 19: Other Products From Premier
Other Products from Premier Premier has other fine water filtration products and accessories to enhance your water and to compliment your existing RO System. Listed on the next several pages are only a few of the items we offer. Visit our web site at www.premierH2o.com or call our Customer Service Representatives at 1-800-752-5582 (inside USA) 1-480-675-7995 (outside USA) for more products. - Page 20 Pool Doc Pool & Spa Water Tester PoolDocTM accurately measures pool and spa chemistry and provides instructions on how to bring the pool/spa back into balance. Part No. 164040 *$189.99/ea Water Pressure Gauge This gauge mounts onto your outside hose connection to accurately show your home’s water pressure up to 300 psi.
- Page 21 Removing chlorine from your shower Special Chlorgon & KDF media – More effective then carbon medias with hot water applications in the removal of the following. √ Free Chlorine (CL-) √ Iron oxide (rust water) √ Combined Chlorine (Sodium Hypochlorite) √...
-
Page 22: Warranty Registration
We want to offer you four ways to communicate with us. 1.Online, 2.Fax, 3.Telephone, and 4. Mail the form below. By registering your product you will receive the full benefit of our warranty. Premier will also send you a semiannual filter change reminder beginning six months from date of installation. - Page 23 Iowa Department of Public Health - Sales in Iowa require this to be completed, signed and returned. These signatures will be retained on file for two years. Insert into envelope and return to Premier Premier 8716 W. Ludlow Dr. Suite #1...
-
Page 24: Service Record
Service Record Model Number:__________ Serial Number:___________ Date of Purchase:__________ Date of Install:___________ Installed by:_____________ Sediment Carbon Membrane Carbon Date Filter Pre-Filter Post-Filter (6 months) (6 months) (2-5 years) (12months) NOTES: Page 24... - Page 25 Page 25...
-
Page 26: Limited Warranty
Limited Warranty What your Warranty Covers: If any part of your Premier Reverse Osmosis System is defective in workmanship (excluding replaceable filters and membranes), return unit after obtaining a return authorization (see below), less tank, within 3 years of original retail purchase, Premier will repair or, at Premier’S option, replace the system at no charge.
Need help?
Do you have a question about the EZ-RO 4 and is the answer not in the manual?
Questions and answers