Table of Contents
Advertisement
4
Introduction ......................................................1
Important Information .........................................1
Safety Precautions ............................................2
Heating Specifications ........................................5
Dimensions.......................................................5
Electrical Specifications......................................5
Fuel.................................................................5
EPA Compliance ................................................5
Before you Begin ...............................................6
Packing List......................................................6
Installation Options ............................................6
Planning the Installation ......................................6
Minimum Fireplace Size .......................................6
Clearances .......................................................7
Mantel Requirements ..........................................7
Hearth Requirements ..........................................7
Facing Requirements ..........................................7
Placing the Insert...............................................7
Venting the Pellet Stove ......................................8
Maximum Venting Distance .............................8
Pellet Vent Type............................................8
Installing the Pellet Vent .................................8
Pellet Vent Termination...................................8
Mobile Home Requirements ..................................9
Outside Air .......................................................9
Restrictor Adjustment .........................................10
Surround Panel & Circuit Board Installation .............11
Installation into a Masonry Fireplace ......................12
Safety Notice ....................................................14
Location of Controls ...........................................14
Starting the Heater for the First Time ......................14
Curing the Paint ............................................14
Priming the Auger ..........................................14
Loading Pellets..................................................15
The Two Modes of Operation ................................15
Travis Industries
Table of Contents
4 0 5 1 2 1 6
Manual Mode.....................................................16
Auto Mode ........................................................17
Restrictor Adjustment .........................................18
Adjusting the Fan Speed......................................18
Start-Up Sequence.............................................19
"AUGER ON" Light..............................................19
"FAULT" Light ....................................................19
Power Outages..................................................19
Inspect the Burn ...........................................20
Make Sure Pellets are not Piling Up ...................20
Check Firepot for Clinkers ...............................21
Cleaning the Firepot .......................................21
Clean the Heat Exchange Tubes.......................22
Vacuum Hopper ............................................22
Clean the Gold Door .......................................22
Opening the Door ..........................................23
Check Ashbox and Ashpan, Dispose.................24
Clean the Glass ............................................24
Sweep Ash Into Ashpan..................................25
Yearly Maintenance (or every two tons) ..................26
Clean the Exhaust Duct ..................................26
Clean the Exhaust Blower ...............................27
Clean the Vent ..............................................27
Replacement Parts ........................................29
Normal Operating Sounds
Normal Operating Sounds ....................................30
Safety Label
Safety Label .....................................................31
Warranty
Warranty ..........................................................32
Gold Grill ..........................................................33
Thermostat .......................................................34
Remote Thermostat ............................................35
Optional Log .....................................................35
Optional Gold Door .............................................35
Index...............................................................36
9 3 5 0 8 0 5 1
Advertisement
Table of Contents
