Advertisement
Quick Links
Etp-5G & Etp-10G
Eco-tEch
Gas convEction stEamEr
parts and sErvicE manual
EffEctivE junE 12, 2015
The Company reserves the right to make substitution in the event that items specified are not available.
ERRORS: Descriptive and/or typographic errors are subject to correction.
44 Lakeside Avenue, Burlington, Vermont 05401 USA Telephone: (802) 658-6600 Fax: (802) 860-3732
tm
Superseding All Previous Parts Lists.
marKEt forGE industriEs
www.mfii.com
P/N 14-0284 Rev D
plus
Advertisement
Related Manuals for Market Forge Industries ECO-TECH PLUS ETp-5G
Summary of Contents for Market Forge Industries ECO-TECH PLUS ETp-5G
- Page 1 The Company reserves the right to make substitution in the event that items specified are not available. ERRORS: Descriptive and/or typographic errors are subject to correction. marKEt forGE industriEs 44 Lakeside Avenue, Burlington, Vermont 05401 USA Telephone: (802) 658-6600 Fax: (802) 860-3732 www.mfii.com...
-
Page 2: Table Of Contents
tablE of contEnts gEnERAL TROUBLShOOTing gUiDE ..........3 ELEcTRicAL FAULT iSOLATiOn gUiDE . -
Page 3: General Troublshooting Guide
GEnEral troublshootinG GuidE problEm probablE causE rEmEdY cOOKing inDicATOR a. main power circuit breaker a. Locate external circuit breaker for LighT FAiLS TO LighT tripped. incoming power and place in On WiTh TimER SET position. b. Door interlock switch contacts closed. - Page 4 GEnEral troublshootinG GuidE problEm probablE causE rEmEdY DOOR LEAKS. a. Damaged door gasket. a. check gasket for cuts and replace. b. clogged compartment drain. b. Remove screen and clean drain line or plumbing. WATER FLOWS inTO a. Level control has failed. a.
-
Page 5: Electrical Fault Isolation Guide
ElEctrical fault isolation GuidE failurE fault location 1. WiLL nOT OPERATE in EiThER hOLD OR 60-minUTE TimER POSi- a. incoming power TiOnS. b. Timer c. Door interlock switch d. Wiring 2. OPERATing in hOLD POSiTiOn BUT nOT in 60-minUTE TimER a. -
Page 6: Troubleshooting
troublEshootinG 60 minutE timEr door intErlocK switch timer contacts malfunction of the cooker door interlock switch prevents indicator lights from turning on and steam generator from Defective timer contacts will result in failure of cooker operating when the timer dial is set. if steam does not compartment to operate. -
Page 7: Adjustments
adjustmEnts All units are adjusted at the factory. in case of operation problems at initial installation, check type of gas supply and mani- fold pressure and compare it with information on the rating plate. problEm probablE causE rEmEdY BURnERS DO nOT a. -
Page 8: Wiring Diagrams
wirinG diaGrams... - Page 9 wirinG diaGrams...
- Page 10 wirinG diaGrams...
- Page 11 wirinG diaGrams...
- Page 12 wirinG diaGrams quantitY itEm part no. dEscription 1 comp 2 comp A 4-22TB Terminal Block B 4-22ES Terminal Block End 9124-2 Switch, On/Off/Delime 4874-1 Thermostat, high Limit Safety ** 4 4038-4 Level control, 10K Ohm 5230-1 Level control, 1m Ohm 3738-9 Probe, Low Level cut-Off 3738-8...
-
Page 13: Steamer Exploded View
stEamEr ExplodEd viEw jUnE 12, 2015 ETP-5g & ETP-10g... - Page 14 stEamEr ExplodEd viEw itEm part no. dEscription Ept-5G Ept-10G 97-6334 compartment Strainer 97-6177 Perforated Trough 97-6175 Pan Rack 97-6174 hinge Rod 97-6269 hinge Rod 97-6191 Door Switch 97-6429 Switch Actuator 97-6178 Striker 97-6554 control Panel Decal 97-6430 control Panel Decal 97-6170 Ready Pilot Light, green, 125V 97-5472...
- Page 15 stEamEr ExplodEd viEw itEm part no. dEscription Ept-5G Ept-10G 97-6438 hose, 5/8" i.D. x 34" Long, Upper cavity Drain 97-6439 hose, 5/8" i.D. x 16" Long, Lower cavity Drain 97-6440 Brass Tee, 3/8"c 97-6188 Brass Elbow, 3/8"c x 1/8" mPT 98-6123 Brass connector, 1/4 c x 1/8"...
- Page 16 stEamEr ExplodEd viEw itEm part no. dEscription Ept-5G Ept-10G 97-6425 Lower Delime hose, 5/8" i.D. x 37" Long 97-6426 Brass hose Barb, 5/8" x 3/4" mPT 97-6203 Brass Tee, 3/4" 97-6204 Brass close nipple, 3/4" 97-6202 Brass Elbow, 3/4" 97-6368 Relief Valve Extension 97-6427 Top Panel...
-
Page 17: Gas Components
Gas componEnts jUnE 12, 2015 ETP-5g & ETP-10g... - Page 18 Gas componEnts itEm part no. dEscription Ept-5G Ept-10G 97-6463 Upper gas Flex Tube, 5/8", O.D. x 42" Long. 97-6457 gas Supply Pipe Assembly 97-6458 Bracket 97-6459 malleable iron Tee, 3/4" x 3/4" x 1/2" 97-6460 nipple, 3/4" x 2" Long 97-5555 90º...
-
Page 19: Cabinet Assembly
cabinEt assEmblY jUnE 12, 2015 ETP-5g & ETP-10g... - Page 20 cabinEt assEmblY itEm part no. dEscription Ept-5G Ept-10G 97-6537 hinge Rod 97-6473 hinge Rod 97-6538 cabinet Door Assembly 97-6539 cabinet Door Assembly ~nPn~ Flat Washer 98-3784 Tempering Tank 97-6421 Brass hose Barb, 5/8" x 3/8" mPT 97-6476 Brass Extruded, 90° Street Elbow, 3/8" ~nPn~ Brass Square head Plug, 3/8"...
- Page 21 cabinEt assEmblY itEm part no. dEscription Ept-5G Ept-10G 08-8064 Elbow, 3/4" nylon 08-8062 nipple, Reducing, 3/4" x 1/2 nPT, nylon 08-8053 check Valve, nylon 97-6547 connector, 3/8" c to 3/8" mPT, nylon 97-6548 Tubing, 3/8" O.D., x 18" Long, nylon ~nPn~ Tubing, 3/8"...