Fivestar & Comet UPRIGHT CARPET SOIL EXTRACTOR SAFETY, OPERATION & MAINTENANCE INSTRUCTIONS MODELS: TR300 FIVESTAR TR419 COMET CAUTION – READ THE INSTRUCTION MANUAL BEFORE USING THE APPLIANCE MACHINE DATA Fivestar & Comet Manual 1/7/15 Page 1 of 25...
Page 2
Website: www.prochem.co.uk All information and specifications in this manual are current at the date of issue. However, because of Prochem Europe policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains variations including accessories used.
CONTENTS PAGE NO. WARRANTY IMPORTANT SAFETY INSTRUCTIONS IMPORTANT OPERATING INSTRUCTIONS GENERAL OPERATING INSTRUCTIONS PRACTICAL CLEANING ACCESSORIES & CHEMICALS GENERAL MAINTENANCE GENERAL FAULT FINDING MACHINE PARTS LIST PUMP PARTS LIST HAND TOOL PARTS LIST WIRING DIAGRAM CE DECLARATION OF CONFORMITY Fivestar & Comet Manual 1/7/15 Page 3 of 25...
Page 4
Prochem Europe Sales Department Telephone: +44 (0)20 8974 1515 Prochem Europe Ltd. EEE Producer Registration Number: WEE / AJ0044SY European Directive (2011/65/EU) Restriction of use of certain Hazardous Substances in Electrical and Electronic Equipment (RoHS2).
Your Prochem unit is designed to give you many years of reliable service. If a problem should arise during or after the warranty period, contact the Prochem Authorised Distributor or the Prochem Service Department, for details of the services available.
Please read this manual completely assembled. carefully and obtain operating instruction from your Prochem Distributor or authorised representative in !! DO NOT attempt repairs or maintenance unless the correct use of this equipment and suitable you are suitably qualified or experienced. Repairs chemicals before attempting to clean.
! DO NOT use boiling water or temperature in excess of 71 ! USE ONLY genuine replacement parts for this machine, supplied by an authorised Prochem ! DO NOT use chemicals in the machine other than Distributor. those manufactured or recommended by Prochem Europe.
Prochem. • Do not use water in excess of 160°F (71°C). Prochem carpet soil extraction machines have been • designed with the operator in mind. Provided you To prevent seal damage and chemical build-up...
To reduce foaming carpet using B109 Fibre & Fabric Rinse. For further in dirty water section of bucket, add Defoamer advice contact Prochem’s technical department. solution according to label instructions. For excessive foam problems introduce Defoamer...
check dirty water side of bucket and add more CLEANING UPHOLSTERY Defoamer solution if required. CLEAN UP CAUTION – WE STRONGLY RECOMMEND Clean lid filter screen and rinse out bucket. ATTENDING AN UPHOLSTERY CLEANING COURSE BEFORE ATTEMPTING TO CLEAN CLEANING HARD FLOORS FABRIC UPHOLSTERY.
10 ml. per litre (1 to 100). Speciality products such as those listed above are available from the Prochem range. Refer to the S709 MULTI PRO chemical section of the Product Catalogue for more A concentrated pre-spotter and traffic lane cleaner details.
GENERAL MAINTENANCE The Prochem Fivestar machine is engineered and Ensure that all connections are secure and built to require a minimum of maintenance. But like close machine electrical housing and secure any machine, it does require some care to keep it in with tool required.
In the event of a reduction in operating pressure, Finding Guide page in this manual and contact your leakage or pump failure, refer to the 'Fault Finding Prochem Distributor. Although some service parts Guide' and contact your Prochem Distributor. are available, we recommend that defective vacuums be replaced.
GENERAL FAULT FINDING GUIDE CAUTION - Repairs should only be carried out by a QUALIFIED AND FULLY TRAINED PERSON ! PROBLEM POSSIBLE CAUSE ELECTRICAL SYSTEM No electrical power Defective power cable House or building circuit breaker tripped Switch is turned on but power is intermittent to all Faulty electrical cable motor(s).
PUMP PARTS LIST STOCK CODE PART NO DESCRIPTION E11162 G11162 150PSI PUMP HEAD (PLEASE REQUEST WHEN PURCHASING THAT BYPASS BE SET TO 85PSI) E11764UHA G11764-1-UHA UPPER HOUSING(FOR E11162) E11764VHA G11764-1-VHA VALVE REPAIR KIT E11764LHA G11764-1-LHA DIAPHRAGM AND DRIVE BEARING ASSY MOTOR 230V AC E11764EBK G11764-1-EBK...
And comply with the requirements of (as amended): 2006/95/EC Low Voltage (LVD) Directive 2004/108/EC Electromagnetic Compatibility (EMC) Directive A Technical file is held by Prochem Europe Ltd. Certificate of compliance and test reports have been issued by: Intertek Testing Sevices SGS United Kingdom Ltd. ETL Testing Laboratories...
Need help?
Do you have a question about the TR300 FIVESTAR and is the answer not in the manual?
Questions and answers