Inspect The Engine For Loose Or Missing Hardware; Inspect The Throttle And Shift Cables For Kinks, Wear And Interference; Inspect The Fuel And Exhaust Systems For Leaks - ILMOR MV8 Owner's Manual

SECTION 4 ILMOR MV8 OWNER'S MANUAL
4-6
INSPECT THE ENGINE FOR LOOSE OR
MISSING HARDWARE
Because this process should be completed while the engine is cool (in
order to avoid burns), it is recommended that this check be completed
prior to starting the engine.
1. Ensure the engine is OFF and the engine safety starting switch is
disconnected. Leave the throttle/shift control lever in neutral. Open the
engine compartment and visually inspect the engine.
2. Systematically check the entire engine for loose and missing hardware.
Attempt to shake components by hand, such as the alternator and the
motor mounts. If a looseness problem exists, it is important to see a
certified Ilmor dealer.
INSPECT THE THROTTLE AND SHIFT
CABLES FOR KINKS, WEAR AND
INTERFERENCE
Because this process should be completed while the engine is cool (in
order to avoid burns), it is recommended that this check be completed
prior to starting the engine.
1. Ensure the engine is OFF and the engine safety starting switch is
disconnected. Leave the throttle/shift control lever in neutral. Open the
engine compartment and locate the throttle/shift cables.
2. Follow each cable back under the floorboards and feel for any kinks
or wear on the outer jacket. Any sign of cable damage is cause for
immediate replacement. See a certified Ilmor dealer for assistance.
INSPECT THE FUEL AND EXHAUST
SYSTEMS FOR LEAKS
These inspections should initially be done before the engine has been
started. Recognize that this is a preliminary inspection only and care
should be taken throughout the boating experience to be alert for any signs
of fuel or exhaust leaks.
1. Ensure the engine is OFF and the engine safety starting switch is
disconnected. Open the engine compartment and visually check as
much of the fuel and exhaust systems as possible.
2. If at any time during operation there is an unexplained odor, or if
anyone on-board shows signs of unexplained drowsiness or sleepiness,
immediately shut down the engine and determine if the odor or
unexplained behavior is the result of malfunctions in the fuel or
exhaust systems.
NOTE: Perform the next pre-checks after the engine has been run for several
minutes and then shut off.
© 5/2013 Ilmor Marine, LLC, Version 1.0