WaterLogic WL3 Firewall Technical Manual
  1. Manuals
  2. Brands
  3. WaterLogic Manuals
  4. Water Dispenser
  5. WL3 Firewall
  6. Technical manual

WaterLogic WL3 Firewall Technical Manual

Hide thumbs

Advertisement

Table of Contents

WL3 Firewall
Technical Manual

Advertisement

Table of Contents
loading

Related Manuals for WaterLogic WL3 Firewall

Summary of Contents for WaterLogic WL3 Firewall

  • Page 1 WL3 Firewall Technical Manual...

  • Page 2: Table Of Contents

    Technical Specifications and Warranties 14. Appliances that are obviously damaged must not be used. End of Life 15. The replacement of the UV lamp must be carried out by personnel trained by Waterlogic International ROHS or their approved distributors. 16. Read the maintenance instructions before opening the appliance.

  • Page 3: Machine Overview

    Machine Overview WL3 FIREWALL SPARKLING COLD TANK The WL3 Firewall is available The sparkling tank is manufactured from 304 Stainless Steel which is noncorrosive. in the following options: The temperature of the sparkling tank is set to 5°C. The capacity of the tank is 1.8 a) Cold, Hot &...
  • Page 4 IN FAUCET UV WATER VALVES Dispensing of water to the customer is achieved by means of a 24V DC electrical The Unique design allows the faucet area to be sterilized before, during and after solenoid valve. The valves are energized every time the customer touches the every dispense.
  • Page 5 Wetted Parts Layout Wetted Parts Layout Cold, Hot and Sparkling Cold, Hot and Ambient CHECK VALVE HOT WATER OUT HOT WATER OUT AIR VENT HOT WATER OUT SOLENOID VALVE IN (Water) SOLENOID AIR VENT VALVE SOLENOID IN (Water) VALVE SPARKLING WATER OUT SOLENOID SUCK VALVE...
  • Page 6 Wetted Parts Layout Wetted Parts Layout Cold and Ambient Cold, Ambient and Sparkling CHECK VALVE AMBIENT WATER OUT SOLENOID AMBIENT WATER OUT IN (Water) VALVE SOLENOID SOLENOID VALVE IN (Water) VALVE SPARKLING WATER OUT SOLENOID SUCK VALVE BACK COLD SENSOR SOLENOID SOLENOID VALVE...

  • Page 7: Carbonation Tank

    CAUTION: Only competent trained technicians should work on Waterlogic products. Waterlogic units may weigh over 25KG. We recommend caution when lifting. Packing materials could present a trip hazard. Keep them off the floor. Take care not to allow the power lead to get wet. If the lead gets wet it must not be used.

  • Page 8: Installation Procedures

    (Report any defects to Waterlogic as soon as possible). 2. Mount the WL3 Firewall on a firm, level surface so the machine cannot topple or fall over. A 50mm air gap is required the whole way around the machine to allow for 2.

  • Page 9: Instructions On Changing The Co 2 Bottle

    Instructions on Changing the CO Bottle 8. Make the water connection using an installation kit. Waterlogic recommends the 1. Turn off the empty CO cylinder and disconnect the CO pressure regulator. use of a pressure reducing valve, a shut off valve and a non return valve. These 2.

  • Page 10: Operating Instructions

    Operating Instructions INSTALLATION KIT The WL3 Firewall must be installed according to the local guidelines and a pressure reducer must be installed as part of the installation. The pressure reducer should Your WL3 is generally ready for use. not be set higher than 3bar.
  • Page 11 Operating Instructions COLD WATER Press the cold water button. Cold water will be dispensed. AMBIENT WATER Press the ambient water but- ton. Ambient water will be dis- pensed. EXTRA HOT WATER Hold down the hot button until the button starts flashing. This SPARKLING WATER means that the water is now heating to the extra hot temperature.

  • Page 12: Maintenance And Servicing

    You will need the following items: are fully removed from the filter to avoid any damage being caused to the machine. • An empty Waterlogic inline filter housing 6. After the filter has been flushed it can be replaced in the WL3 Firewall and the • Rubber gloves water pipes can be reconnected.
  • Page 13 3. Measure 45ml of Aqua Dosa sanitising fluid into the empty filter housing and DE-SCALING securely fasten the filter head. You will need the following items to descale the hot tank. 4. Insert the water feed pipe into the inlet fitting of the inline filter housing containing • A container that can hold 5 litres of water sanitisation fluid.

  • Page 14: Fault Finding

    The pump will time out if it FILTRATION LED runs for more than 8 minutes continuously. 8. Bad or plastic taste: If the WL3 Firewall is new it may need flushing for a longer Filtration is Active. period.

  • Page 15: Technical Specifications And Warranties

    1/4” Hose 1/4” Hose 1/4” Hose 1/4” Hose 1/4” Hose • Engagement of untrained personnel Connection Minimum Water Pressure Waterlogic has a policy of constant and continual improvement and therefore 0.26 (2.6) 0.26 (2.6) 0.26 (2.6) 0.26 (2.6) 0.26 (2.6) 0.26 (2.6) 0.26 (2.6) Megapascal...

  • Page 16: End Of Life

    ROHS All Waterlogic machines comply with EC Directive (2002/95/EC) on the Restriction of the Use of Certain Hazardous Substances in Electrical and Electrical Equipment (RoHS BIOCOTE® (ANTI-MICROBIAL SOLUTION) For your added protection this product incorporates BioCote®...
  • Page 17 Wetted Parts List Hot, Cold and Sparkling N° Part Description 52 51 JG Equal Elbow Connector 1/4" (PI0308S) JG Bulkhead Connector Union 1/4" * 1/4" 1/4" PE Pipe JG Non-Return Valve 1/4" 1/4" PE Pipe JG Equal Straight Connector 1/4" JG Equal Straight Connector 1/4"...
  • Page 18 Wetted Parts List Hot, Cold and Sparkling N° Part Description JG Equal Tee Connector 1/4" 1/4" PE Pipe JG Equal Elbow Connector 1/4" (PI0308S) JG Equal Elbow Connector 1/4" (PI0308S) JG Equal Elbow Connector 1/4" (PI0308S) JG Equal Elbow Connector 1/4" (PI0308S) Solenoid Valve DC24V 1000mm 1/4"...
  • Page 19 Main Parts List WL3 Mains Parts Illustration N° Part Description WL3 Top Cover Black FS Back Panel for 850 Silver Switch - Heater/Compressor (Green) Power Switch(Red)-No back lights JG Bulkhead Connector Union 1/4" * 1/4"(PI1208S) Fuse Holder & Fuse 220V/10A with only one wire Gasket for Power Socket Socket for Plug Connection (Domestic PST-101SL) Thermostat...
  • Page 20 N° Part Description N° Part Description Universal FS Filter Bracket for 950,650,850 UV Lamp Retaining Threaded Nut WL750 (Ugrade of PL-1047) Drain valve ASM UV Lamp Retaining Nut 2,8" Filter Clip Stainless Cap for WL3 & WL850 Tank JG Equal Elbow Connector 1/4" (PI0308S) 15W 220v/50Hz Electronic Ballast Filter O-ring (Black Quartz Sleeve)
  • Page 21 Speak to a Water Expert USA, Canada and Mexico exportsales@waterlogic.com info@waterlogicusa.com + 353 1 293 1960 + 1 402 884 7212 WLI Trading Ltd. Waterlogic USA, 11710 Stonegate Circle Suite 4, 2nd Floor Beacon Court, Omaha, NE 68164 Sandyford, Dublin 18, Ireland www.waterlogic.com...

Table of Contents