Table Of Contents - Lenovo THINKPAD T510 Hardware Maintenance Manual

Contents
About this manual. . . . . . . . . . .
Chapter 1. Safety information . . . . . 1
General safety . . . . . . . . . . . . . . . .
Electrical safety . . . . . . . . . . . . . . .
Safety inspection guide . . . . . . . . . . . .
Handling devices that are sensitive to electrostatic
discharge. . . . . . . . . . . . . . . . . .
Grounding requirements . . . . . . . . . . . .
Safety notices (multilingual translations) . . . . . .
Laser compliance statement (multilingual
translations) . . . . . . . . . . . . . . . .
Chapter 2. Important service
information . . . . . . . . . . . . . . 25
Strategy for replacing FRUs . . . . . . . . .
Strategy for replacing a hard disk drive or solid
state drive. . . . . . . . . . . . . . .
Important notice for replacing a system
board . . . . . . . . . . . . . . . .
How to use error message . . . . . . . .
Strategy for replacing FRUs for CTO, CMV, and
GAV . . . . . . . . . . . . . . . . . . .
Product definition . . . . . . . . . . . .
FRU identification for CTO, CMV, and GAV
products . . . . . . . . . . . . . . .
Chapter 3. General checkout . . . . . 29
What to do first . . . . . . . . . . . . . .
Checkout guide . . . . . . . . . . . . . .
Diagnostics using PC-Doctor for DOS. . . .
Lenovo ThinkVantage Toolbox (Lenovo System
Toolbox) . . . . . . . . . . . . . . .
PC-Doctor for Rescue and Recovery . . . .
FRU tests . . . . . . . . . . . . . . .
Power system checkout . . . . . . . . . . .
Checking the ac adapter . . . . . . . . .
Checking operational charging . . . . . .
Checking the battery pack . . . . . . . .
Checking the backup battery . . . . . . .
Chapter 4. Related service
information . . . . . . . . . . . . . . 39
Restoring the factory contents by using Recovery
Disc Set . . . . . . . . . . . . . . . . .
Passwords . . . . . . . . . . . . . . . .
Power-on password . . . . . . . . . . .
Hard-disk password. . . . . . . . . . .
Supervisor password . . . . . . . . . .
© Copyright Lenovo 2009, 2011
iii
How to remove the power-on password . . .
How to remove the hard-disk password . . .
Power management
1
Screen blank mode . . . . . . . . . . .
2
Sleep (standby) mode . . . . . . . . . .
3
Hibernation mode
Symptom-to-FRU index . . . . . . . . . . .
3
Numeric error codes
4
Error messages . . . . . . . . . . . .
4
Beep symptoms . . . . . . . . . . . .
No-beep symptoms . . . . . . . . . . .
17
LCD-related symptoms . . . . . . . . .
Intermittent problems . . . . . . . . . .
Undetermined problems . . . . . . . . .
25
Chapter 5. Installing and configuring
RAID . . . . . . . . . . . . . . . . . . 53
26
Supported RAID configurations . . . . . . . .
26
Configuring the system BIOS to enable embedded
SATA RAID functionality . . . . . . . . . . .
26
Creating RAID volumes . . . . . . . . . . .
26
Deleting RAID volumes . . . . . . . . . . .
26
Chapter 6. Status indicators . . . . . 55
27
Chapter 7. Fn key combinations . . . 59
Chapter 8. FRU replacement
29
notices . . . . . . . . . . . . . . . . 63
30
Screw notices . . . . . . . . . . . . . . .
30
Retaining serial numbers. . . . . . . . . . .
33
Restoring the serial number of the system
unit . . . . . . . . . . . . . . . . .
34
Retaining the UUID . . . . . . . . . . .
34
Reading or writing the ECA information . . .
35
35
Chapter 9. Removing and replacing a
36
FRU . . . . . . . . . . . . . . . . . . 67
36
Before servicing ThinkPad T510, T510i, and
37
W510 . . . . . . . . . . . . . . . . . .
1010 Battery pack . . . . . . . . . . . . .
1020 Serial Ultrabay Enhanced device or travel
bezel . . . . . . . . . . . . . . . . . .
1030 DIMM slot cover . . . . . . . . . . . .
39
1040 DIMM (bottom slot). . . . . . . . . . .
40
1050 Hard disk drive slot cover, hard disk drive and
40
HDD rubber rails or solid state drive and storage
40
converter . . . . . . . . . . . . . . . . .
41
1060 Keyboard . . . . . . . . . . . . . .
. . . . . . . . . . . .
. . . . . . . . . . .
. . . . . . . . . .
41
41
42
42
42
43
43
44
48
49
50
50
50
51
53
53
53
54
63
64
64
65
65
68
68
69
70
70
71
73
i