Add Engine Oil; Add Fuel - Troy-Bilt 1904 Owner's Manual

Section 3: Assembly
2. Secure tray to handle with self tapping screws using a
#2 phillips screwdriver. Ensure screws are tight but not
crushing the plastic accessory tray.
3. Place the handle assembly onto the handle supports
connected to the main unit. Make sure the holes in the
handle align with the holes on the handle supports
(Figure 2).
Figure 2 — Attach Handle to Base
Align Holes
NOTE: It may be necessary to move the handle supports
from side to side in order to align the handle so it will slide
over the handle supports.
4. Insert the "L" bolt through the hole on the left side of
the handle (viewing from handle side of unit) and attach
the plastic knob.Tighten the knob by hand (Figure 3).
Figure 3 — Secure Handle
5. Insert the carriage bolt through the right side hole
from the outside of the unit and attach a plastic knob
from the inside of the unit (viewing unit from the
handle side).Tighten by hand (Figure 3).
6. Insert the "J" hook into the second from the left slot in
the accessory tray (Figure 4).
Figure 4 — Install "J" Hook on Accessory Tray
Handle
Handle
Supports
7. Pinch the chemical hose and slide it into the metal clip
as shown in Figure 5.
Figure 5 — Slide Chemical Hose into Metal Clip
8. Tilt the unit up by the handle and attach the metal clip
to the rib on the center underside of the accessory
tray (Figure 6). Slide the chemical hose through the
metal clip so that it is tight but not kinked.
Figure 6 — Slide Metal Clip onto Accessory Tray Flange

Add Engine Oil

IMPORTANT: Any attempt to crank or start the engine
before it has been properly serviced with the
recommended oil may result in an engine failure.
• Place pressure washer on a level surface.
• Refer to the engine owners manual to add recommended
oil to engine.
NOTE: Check oil often during engine break–in. Refer to
engine owner's manual for recommendations.

Add Fuel

WARNING!
fill fuel tank when engine is running or hot. Allow
unit to cool for two minutes before refueling. DO
NOT light a cigarette or smoke when filling the fuel
tank.
6
NEVER fill fuel tank indoors. NEVER