Related Manuals for Pentair T53
Summary of Contents for Pentair T53
-
Page 1: Air Conditioner
T-SERIES Air Conditioner t53 Model INSTRUCTION MANUAL © 2013 Pentair Equipment Protection 88004712 Rev. F P/N 10-1008-224... -
Page 2: Table Of Contents
NOTE: Some of the information in this manual may not apply if a special unit was ordered. If additional drawings for a special unit are necessary, they have been inserted. Contact Pentair Equipment Protection if further information is required. © 2013 Pentair Equipment Protection... -
Page 3: Receiving The Air Conditioner
Damage evident upon receipt should be noted on the freight bill. Damage should be brought to the attention of the delivering carrier -- NOT to Pentair Equipment Protection -- within 15 days of delivery. Save the carton and packing material and request an inspection. Then file a claim with the delivering carrier. -
Page 4: Installation Instructions
Amb Temp °F/°C Weight lb./kg T531926GXXX 50/60 17.3/20.3 16,800/19,000 131/55 197/89 XXX will be replaced with a three-digit number designating all desired options. Consult the factory for specific model numbers. DIMENSIONAL DRAWING © 2013 Pentair Equipment Protection 88004712 - 4 -... -
Page 5: Mounting Cutout Dimensions
MOUNTING CUTOUT DIMENSIONS Surface Mount Recess Mount CUTOUT INSTRUCTIONS (As viewed from outside of enclosure) NOTE: Dashed lines represent air conditioner. © 2013 Pentair Equipment Protection 88004712 - 5 -... -
Page 6: Components List
89098474 Coil, Evaporator 53-1001-00 Air Filter, Reusable 89057627 Filter/Dryer 52-6028-06 Thermal Expansion Valve 10-1040-40 Freeze Stat 10-1061-05 Head Pressure Control Switch 52-6104-53 Malfunction Limit Switch (Optional) 52-6104-54 Thermostat, SPDT, 60-101F 10-1061-03 © 2013 Pentair Equipment Protection 88004712 - 6 -... -
Page 7: Wiring Diagram (With Optional Heater)
WIRING DIAGRAM (WITH OPTIONAL HEATER) © 2013 Pentair Equipment Protection 88004712 - 7 -... -
Page 8: Temperature Control
Continued operation under the above conditions can and will damage and shorten compressor life. The air conditioner features an easily removable inlet filter to facilitate necessary cleaning. There should be no reason to neglect this necessary maintenance. © 2013 Pentair Equipment Protection 88004712 - 8 -... -
Page 9: How To Remove, Clean Or Install A New Inlet Air Filter
CAUTION Operation of the air conditioner in areas containing airborne caustics or chemicals can rapidly deteriorate filters, condenser coils, blowers and motors, etc. Contact Pentair Equipment Protection for special recommendations. REFRIGERANT LOSS Each air conditioner is thoroughly tested prior to leaving the factory to insure against refrigeration leaks. Shipping damage or microscopic leaks not found with sensitive electronic refrigerant leak detection equipment during manufacture may require repair or recharging of the system. -
Page 10: Trouble Shooting
(replace control box cover for safety). This will pass the switch in the thermostat. Turn the power on and if both blowers and the compressor come on, the thermostat needs to be replaced. © 2013 Pentair Equipment Protection 88004712 - 10 -... -
Page 11: Symptoms And Possible Causes
Short in system Drain plugged Getting water in enclosure Drain tube kinked Enclosure not sealed (allowing humidity in) For additional technical support (i.e., amp draw, pressures, temperatures), contact Pentair Equipment Protection at 800-896-2665. © 2013 Pentair Equipment Protection 88004712 - 11 -... - Page 12 NOTES © 2013 Pentair Equipment Protection 88004712 - 12 -...
- Page 13 NOTES © 2013 Pentair Equipment Protection 88004712 - 13 -...
-
Page 14: Warranty
Pentair Equipment Protection approval. Pentair Equipment Protection must be notified of a claim in writing not later than fourteen (14) days from the date when Buyer has become aware of such occurrence, or where the defect is such that it may cause damage, immediately, such notice containing a description of how the defect manifests itself. -
Page 15: Limitation Of Liability
B. All returns to Pentair Equipment Protection must be securely packed, using original cartons if possible. All returns must have the RMA number visible on the outside of the carton. Pentair Equipment Protection is not responsible for material damaged in transit. Any refrigerant-bearing Goods must be shipped upright for return. - Page 16 Pentair Equipment Protection 2100 Ho man Way Minneapolis, MN 55303 USA +1.763.422.2211 +1.763.576.3200 PentairEquipmentProtection.com © 2013 Pentair Equipment Protection 88004712 Rev. F P/N 10-1008-224...