Required Tools & Parts - Harsco Industrial MACH C750 Installation & Owner's Manual

®
See this MACH C750-C1050 Outdoor Boiler Manual & MACH
additional information. Incorrect installation may result in severe injury or death.
enclosure. All exhaust venting and air intake must be outdoors. All installations of venting systems should be
done only by qualified venting systems personnel. Venting must be installed in accordance with vent system
manufacturer's installation instructions and this manual.
installation methods or materials can result in serious injury or death due to fire or asphyxiation from carbon
monoxide or other poisonous gases. Breathing exhaust fumes may cause serious personal injury or death.
WARNING
!
Improper use may
result in fire or injury.
Read instructions/safety
manual before installing,
operating or servicing boiler.
c
1998 HCS, Inc. 800-748-0241 Reorder No. 6020-V2WHPK
1.2 R T
EQUIRED
The following tools are required for the installation of the MACH
®
MACH Outdoor Boiler.
Pipe wrench (for 1" pipe elbow).
Tape measure.
Cordless drill / screw driver..
Phillipshead driver / screwdiver
¼" socket driver for #6 self tapping screws.
Approved gas pipe sealant.(See section 2.2)
Small tube of 100% silicone.
Approved exhaust vent sealer. (See Section 2.3 / 2.4)
Approved PVC cleaner & solvent.
Customer Supplied Parts
Exhaust Adapter
Exhaust pipe
Seal tight connector
Waterproof conduit
Shut off and disconnect electric and gas before installing the MACH
The boiler and these instructions is for outdoor use only. Do not install in any
Manual for specific safety requirements, warnings, installation requirements
and diagrams. These instructions are a supplemental document which should
be used in conjunction with the MACH
Manual for your specific MACH
outdoor use only. Incorrect installation may result in injury or death.
& P
OOLS ARTS
MACH
®
C750-C1050 Installation & Owner's Manual for
Installing a boiler or vent system using improper
®
See MACH C750-C1050 Installation & Owner's
®
C750-C1050 Installation & Owner's
®
Boiler. The boiler and these instructions is for
®
Outdoor Boiler loose parts on a new
4
®
C750-C1050 Outdoor Boilers
®
Outdoor Boiler.