1. Manuals
  2. Brands
  3. Winnebago Manuals
  4. Motorhomes
  5. 2011 sunova
  6. Operator's manual

Winnebago 2011 sunova Operator's Manual

Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
About this Manual ............................................................................................................................. 1-1
Safety Messages Used in this Manual ............................................................................................... 1-1
Pre-Delivery Inspection .................................................................................................................... 1-2
Front Axle Tire Alignment ................................................................................................................ 1-2
Service and Assistance ...................................................................................................................... 1-2
Reporting Safety Defects .................................................................................................................. 1-2
Occupant and Cargo Carrying Capacity Label ................................................................................. 1-3
Vehicle Certification Label ............................................................................................................... 1-4
specifications and Capacities ............................................................................................................ 1-5
Owner and Vehicle Information ........................................................................................................ 1-6
2011 New Vehicle Limited Warranty ............................................................................................... 1-7
General Warnings .............................................................................................................................. 2-1
Driving Safety ................................................................................................................................... 2-1
Fuel and Propane Gas ........................................................................................................................ 2-1
LP Gas Leaks .................................................................................................................................... 2-2
Propane Gas Leak Detector ............................................................................................................... 2-2
Carbon Monoxide Warning ............................................................................................................... 2-3
Carbon Monoxide Alarm .................................................................................................................. 2-3
Smoke Alarm .................................................................................................................................... 2-4
Fire Extinguisher ............................................................................................................................... 2-4
Electrical ........................................................................................................................................... 2-5
Loading ............................................................................................................................................. 2-5
Maintenance ...................................................................................................................................... 2-5
Emergency Exits ............................................................................................................................... 2-5
Slideout Rooms ................................................................................................................................. 2-6
Formaldehyde Information ................................................................................................................ 2-6
Mold, Moisture, and Your Motor Home ........................................................................................... 2-7
Roof and Ladders .............................................................................................................................. 2-8
Roadside Emergency ......................................................................................................................... 2-8
Jump Starting .................................................................................................................................... 2-9
Engine Overheat ................................................................................................................................ 2-9
Seats - Driver/Co-Pilot ..................................................................................................................... 3-1
Seat Belts ........................................................................................................................................... 3-2
Child Restraints ................................................................................................................................. 3-3
KeyOne™ Lock System .................................................................................................................... 3-4
Rearview Monitor System ................................................................................................................. 3-4
Rev. 1118110725

TABLE OF CONTENTS

Copyright 2010 Winnebago Industries, Inc. All rights reserved.
Part No. 161500-11-010

Advertisement

Table of Contents
loading

Related Manuals for Winnebago 2011 sunova

Summary of Contents for Winnebago 2011 sunova

  • Page 1: Table Of Contents

    3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Seat Belts ............................3-2 Child Restraints ..........................3-3 KeyOne™ Lock System ........................3-4 Rearview Monitor System ......................... 3-4 Rev. 1118110725 Part No. 161500-11-010 Copyright 2010 Winnebago Industries, Inc. All rights reserved.
  • Page 2 Table Of Contents 12-Volt Front Drop-Down Solar/Night Shade .................. 3-5 Mirrors – Power Electric ........................3-6 Brake-Shift Interlock ........................3-7 Park Brake – Foot Pedal ........................3-7 Tow/Haul Transmission Mode ......................3-7 Map Light Switch ..........................3-7 Hazard Warning Flashers ........................3-7 Battery Boost Switch ........................
  • Page 3 Table Of Contents 6 – ELECTRICAL Electrical Cautions ..........................6-1 Electrical System – House 120-Volt AC ..................6-1 External Power Cord ......................... 6-1 Inverter Unit – 1000W ........................6-2 Power Center ............................. 6-3 Circuit Breakers – House 120-Volt AC .................... 6-4 Electrical Outlets –...
  • Page 4 Table Of Contents Exterior Entertainment Center ......................8-7 Exterior Entertainment Center ......................8-7 9 – FURNITURE AND SOFTGOODS Lounge Chair – Swivel Glider ......................9-1 Buffet Table and Chairs ........................9-2 Sleeping Facilities ..........................9-3 Dinette/Bed Conversion ........................9-3 Sofa/Bed Conversion ........................9-4 Comfort Sofa Sleeper ........................
  • Page 5 Table Of Contents 12 – MISCELLANEOUS Loading the Vehicle ........................12-1 Weighing Your Loaded Vehicle ..................... 12-1 Car or Trailer Towing ........................12-3 Trailer Wiring Connector ........................ 12-4 Towing Guidelines .......................... 12-4 Fireplace ............................12-5 Entry Step – Electric ........................12-6 Windows ............................

  • Page 7: Introduction

    DANGER indicates a hazardous situation are intended as a guide, and in no way which, if not avoided, will result in death or extend the responsibilities of Winnebago serious personal injury. Industries beyond the standard written warranty as presented in this manual.

  • Page 8: Pre-Delivery Inspection

    National Highway Traffic Safety Administration delivery inspection of the chassis and all motor (NHTSA) in addition to notifying Winnebago home components. Industries, Inc. As a part of the pre-delivery inspection...

  • Page 9: Occupant And Cargo Carrying Capacity Label

    SECTION 1 – INTRODUCTION or go to their website at http://www.safercar.gov or write to: Administrator, NHTSA 1200 New Jersey Avenue S.E. Washington, D.C. 20590 You can also obtain other information about motor vehicle safety from the NHTSA website at http://www.safercar.gov OCCUPANT AND CARGO CARRYING CAPACITY LABEL This label is affixed in the driver’s area next to...

  • Page 10: Vehicle Certification Label

    These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.

  • Page 11: Specifications And Capacities

    SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES Standard Optional ® ® ® ® Ford Ford Ford Ford ® ® Ford Ford Itasca Sunova 22,000 lb. 22,000 lb. 22,000 lb. 22,000 lb. 22,000 lb. 22,000 lb. Chassis with Chassis with Chassis with Chassis with Chassis with Chassis with...

  • Page 12: Owner And Vehicle Information

    Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...

  • Page 13: 2011 New Vehicle Limited Warranty

    Chassis, drivetrain and related components* Winnebago Industries, Inc. of Forest City, Iowa, warrants each new Wheels* Winnebago and Itasca motor home to the owner for recreational use Tires* in the U.S.A. and Canada as follows: Any other part or component covered by a written warranty issued by...
  • Page 14 If you are touring or have moved, contact any unresolved warranty disputes for recreational vehicles. This dispute Winnebago Industries motor home dealer in the United States or resolution program reviews eligible product and service related Canada for warranty service.

  • Page 15: Safety And Precautions

    SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...

  • Page 16: Lp Gas Leaks

    SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.

  • Page 17: Carbon Monoxide Warning

    SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly WARNING maintained engine exhaust and ventilation system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.

  • Page 18: Smoke Alarm

    InfoCase for further instructions. that is also listed for RV application. We Replacement recommend obtaining a replacement from your ® Winnebago Industries dealer. When replacing this alarm, we recommend replacing only with the same model, or with one Further Information that is also listed for RV application.

  • Page 19: Electrical

    MAINTENANCE your coach. We recommend obtaining a replacement only from your Winnebago • Do not remove the radiator cap while engine ® Industries dealer or a reliable RV parts supplier.

  • Page 20: Slideout Rooms

    SECTION 2 – SAFETY AND PRECAUTIONS SLIDEOUT ROOMS WARNING Your motor home may have more than one slideout room. Understand which switch operates which slideout room prior to operation. Make sure all slideout rooms are clear of people who could be harmed or obstacles that could cause damage prior to operating any slideout rooms.

  • Page 21: Mold, Moisture, And Your Motor Home

    Winnebago Industries ® of the nature of the use of a motor home, it is natural for a motor home to be introduced into an If Winnebago Industries determines that mold environment with mold spores. ® ® is present in the Winnebago...

  • Page 22: Roof And Ladders

    SECTION 2 – SAFETY AND PRECAUTIONS warranty period, Winnebago Industries will not • Make sure you are physically capable to provide any financial assistance to the repair of safely use the ladder. Strength, flexibility, and the condition. stability are required.

  • Page 23: Jump Starting

    We recommend that you ask for an underlift parts of the vehicle will occur. (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume responsibility for damage incurred while towing ENGINE OVERHEAT this vehicle.
  • Page 24 SECTION 2 – SAFETY AND PRECAUTIONS NOTICE Operating a vehicle under a severe overheating condition can result in damage to the vehicle. For information on what to do in case of overheating, consult your chassis manual. 2-10...

  • Page 25: Driving Your Motor Home

    SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to features installed or adapted to the dash and Lift to Recline driver compartment area by Winnebago ® Industries . It also includes passenger seating in the living area of the coach.

  • Page 26: Seat Belts

    SECTION 3 – DRIVING YOUR MOTOR HOME SEAT BELTS Seats intended for occupancy while the vehicle is in motion are equipped with seat belts for the protection of the driver and passengers. Lap Belts The lap belts must be worn as low as possible and fit snugly across the hip area.

  • Page 27: Child Restraints

    SECTION 3 – DRIVING YOUR MOTOR HOME • Inspect the belts and hardware periodically. Check for cuts, frays, and loose parts. WARNING Damaged parts should be replaced. Do not remove or modify the belt system. • Keep belts clean and dry. If the belts need Snug and low belt positions are essential.

  • Page 28: Keyone Lock System

    Tether Anchor Loop The key number for your coach is registered in our factory database, so if you ever lose your ® keys, any Winnebago Industries dealership can order a new key for you. REARVIEW MONITOR SYSTEM –If Equipped NOTE: The dinette table must be in the lowered position when a child seat is in use.

  • Page 29: 12-Volt Front Drop-Down Solar/Night Shade

    SECTION 3 – DRIVING YOUR MOTOR HOME Basic Operating Instructions 12-VOLT FRONT DROP-DOWN SOLAR/NIGHT SHADE –If Equipped Your coach may be equipped with a 12V Power Front Drop-Down Solar/Night Shade that • Turn ON to activate monitor for rear viewing provides privacy and solar heat protection as well while driving or parked.

  • Page 30: Mirrors - Power Electric

    SECTION 3 – DRIVING YOUR MOTOR HOME Refer to the Solar/Night Shade manufacturer’s information provided in your InfoCase. Further Information Refer to the manufacturer’s user guide provided in your InfoCase for complete operating instructions, troubleshooting tips, and maintenance care. MIRRORS – POWER ELECTRIC –If Equipped Always adjust mirrors for maximum rear Mirror Heat Switch...

  • Page 31: Brake-Shift Interlock

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information BRAKE-SHIFT INTERLOCK See the chassis manual in your InfoCase for ® Ford Chassis further operating instructions and cautions. The Brake-Shift Interlock is a safety feature MAP LIGHT SWITCH that prevents the shift lever from being moved from the Park position unless the ignition is ON Turn the driver side map light on using the and the service brake pedal is pressed.

  • Page 32: Air Conditioner/Heater - Automotive (Dash)

    SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: The House/Coach Battery Disconnect HEATER – REAR COACH switch near the entrance door must be (AUTOMOTIVE) ON and house batteries must be sufficiently charged for this feature to –If Equipped work. To provide auxiliary automotive system heat to the rear of the vehicle while driving, turn the rear heater fan switch to the desired speed.

  • Page 33: Radio - In-Dash

    SECTION 3 – DRIVING YOUR MOTOR HOME powered by house batteries. If the Coach/ House Battery Disconnect Switch is off, the speakers will not emit sound. Defrost Fan Switch -Typical View Radio Power Switch RADIO - IN-DASH • Press HOUSE to listen to the radio while parked without the ignition key on.

  • Page 34: Front Service Access

    SECTION 3 – DRIVING YOUR MOTOR HOME CB Power Wires (in plastic sheath) Front Hood Latch Typical View - your coach may differ FRONT SERVICE ACCESS (HOOD) The hood panel can be opened for access to service items such as: •...

  • Page 35: Engine Cooling System

    SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: On some models the beverage tray (if equipped) may need to be removed to provide additional clearance to extract the engine cover. If the beverage tray has a drawer, it must be removed to expose the fasteners that hold the tray to the motor cover.

  • Page 36: Chassis Battery Disconnect Switch

    SECTION 3 – DRIVING YOUR MOTOR HOME CHASSIS BATTERY SUSPENSION ALIGNMENT DISCONNECT SWITCH AND TIRE BALANCE The front suspension and steering system of The Chassis Battery Disconnect switch this vehicle was factory aligned using highly disconnects most chassis electrical loads from accurate equipment prior to delivery to the the chassis (starting) batteries to avoid discharge dealership.

  • Page 37: Circuit Breakers And Fuses - Chassis/Dash Automotive 12-Volt

    SECTION 3 – DRIVING YOUR MOTOR HOME Further Information Refer to the chassis manual in your InfoCase for further information. CIRCUIT BREAKERS AND FUSES – CHASSIS/DASH AUTOMOTIVE 12-VOLT The 12-volt automotive fuses and breakers are conveniently located behind the panel beneath the left end of the dash in front of the driver’s seat.

  • Page 39: Appliances And Systems

    SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home are manufactured by reputable RV appliance makers and have been tested by independent laboratories to meet all applicable standards and codes set for RV appliances. See Section 2 - Safety and Precautions of this manual for any safety and precautions you need to take regarding the operation of your appliances.

  • Page 40: Ice Maker

    SECTION 4 – APPLIANCES AND SYSTEMS NOTE: A water shut-off valve for the ice maker is located near the water faucet filter inside the galley cabinet beneath the sink. Further Information See the refrigerator manufacturer’s operation, care and maintenance information in your InfoCase.

  • Page 41: Range And Oven

    SECTION 4 – APPLIANCES AND SYSTEMS Oven Burner Knob –If Equipped • Pilot On position keeps pilot flame lit for repeated Refrigerator Access Compartment use of oven while vehicle is parked • Turn oven knob to Pilot Off position while traveling or refilling propane gas tank RANGE AND OVEN To Light Oven Pilot...

  • Page 42: Microwave Oven

    SECTION 4 – APPLIANCES AND SYSTEMS WARNING Portable fuel-burning equipment including wood and charcoal grills and stoves, shall not be used inside the recreational vehicle. The use of this equipment inside the recreational vehicle can cause fires or asphyxiation. Failure to comply could result in death or serious injury.
  • Page 43 SECTION 4 – APPLIANCES AND SYSTEMS battery and house battery condition. You can start the generator and check the generator hourmeter or turn on the water pump and water heater. Generator Start/Stop Switches and Sensors Hourmeter See Section 6 - Electrical for generator start- up/shut-down and generator hourmeter instructions.

  • Page 44: Water Heater - Gas/ Electric

    SECTION 4 – APPLIANCES AND SYSTEMS • An interior light should be turned on to WATER HEATER - GAS/ provide a small load which draws off the ELECTRIC battery surface charge. The Gas/Electric Water Heater has a dual Water Heater Switches power feature.

  • Page 45: Motoraid Water Heater

    SECTION 4 – APPLIANCES AND SYSTEMS For Electric Operation Press the Water Heater Electric switch to ON. The shoreline must be connected or generator NOTICE running for electric operation. Any leak in the heat exchanger or its supply or return lines could cause loss of coolant and subsequent engine failure.

  • Page 46: Power Control System (Pcs)

    SECTION 4 – APPLIANCES AND SYSTEMS POWER CONTROL SYSTEM (PCS) CAUTION –If Equipped The Power Control System (PCS) monitors Hot water can escape from tank causing the electrical usage of the appliances and injury. Operate this valve only when the water heater and engine cooling system equipment in the coach and allows you to use are cold.

  • Page 47: Heat Pump

    SECTION 4 – APPLIANCES AND SYSTEMS Further Information Please see the furnace operating instructions provided in your InfoCase for further information, including operating precautions, and periodic maintenance. See the Coach Maintenance Schedule for recommended intervals. NOTE: If the furnace burner has any residuals of metal protectant or lubricants used during manufacture of the furnace, it may smoke slightly when the furnace is...

  • Page 48: Ducted Roof Air Conditioning System

    SECTION 4 – APPLIANCES AND SYSTEMS temperatures begin to reduce the efficiency of the NOTE: The ducted roof air conditioning system heat pump. The heat pump will not operate when has ceiling registers that can be closed if the outside temperature falls below 36 degrees F. necessary to force more cool air toward a specific area of the coach or to route To operate the heat pump:...

  • Page 49: Furnace-A/C Thermostat Operation Chart

    SECTION 4 – APPLIANCES AND SYSTEMS FURNACE-A/C THERMOSTAT OPERATION CHART The following chart shows the system functions with the “Heat/Cool” thermostat. Disregard references to heat functions when using the “Cool Only” thermostat in the rear bedroom. X = Switch Position O = Switch position does not matter or is inactive for this feature FAN MODE FAN SPEED...

  • Page 51: Propane Gas

    SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.

  • Page 52: Safe Use Of The Propane Gas System

    SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN G E R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.

  • Page 53: Propane Gas Warnings And Precautions

    SECTION 5 – PROPANE GAS • Exercise caution at all times. Be familiar with PROPANE GAS WARNINGS the distinctive odor of propane gas. If a leak is AND PRECAUTIONS suspected, turn off the supply valve immediately. Have the propane gas system It is illegal for vehicles equipped with propane checked by your dealer or other qualified tanks to travel on certain roadways or through...

  • Page 54: Propane Gas Pressure Regulator

    SECTION 5 – PROPANE GAS WARNING WARNING Propane cylinders shall not be placed or Visually inspect the pressure regulator stored inside the vehicle. Propane vent periodically for blockage by cylinders are equipped with safety accumulated debris or insect nests, etc. devices that relieve pressure by Vent obstruction could result in excessive discharging propane to the atmosphere.

  • Page 55: Propane Vaporization In Cold Weather

    SECTION 5 – PROPANE GAS This means that in extremely cold weather when a large volume of gas is being used by the furnace for heating, it is possible to experience a loss of gas pressure. At first, this problem may appear to be caused by an empty tank or a regulator freeze-up, but is actually caused by failure of the liquid gas to vaporize as fast as it is needed by the furnace.

  • Page 57: Electrical

    SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...

  • Page 58: Inverter Unit - 1000W

    SECTION 6 – ELECTRICAL be used is designed to mate with the prongs of the power cord plug, the electrical connection can be expected to carry rated load. Connecting The Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable 50-amp power receptacle to provide external power to the coach and converter/...

  • Page 59: Power Center

    SECTION 6 – ELECTRICAL NOTE: The inverter is not intended for steady use while “dry camping”. Batteries will deplete quickly with use of the inverter. The inverter is intended for limited, short term power usage when not connected to shoreline or generator power. The inverter can also be used while driving the motor home because the Inverter Control Panel...

  • Page 60: Charging Section

    SECTION 6 – ELECTRICAL Charging Section The converter charges house batteries while 120-volt external power is connected. The converter will automatically “sense” the condition of the battery. If it is below “full charge”, the Charging Section will start charging the batteries. If the house batteries have been extremely discharged, they will accept charge at a relatively high amperage rate.

  • Page 61: Electrical Outlets - House 120-Volt Ac

    SECTION 6 – ELECTRICAL component itself. When an overload or short GROUND FAULT CIRCUIT develops, the breaker will open preventing INTERRUPTER damage to the system. Shut off the equipment (example: roof air Bath, galley, and exterior outlets are conditioner) and allow a brief cooling period. connected to a GFCI (Ground Fault Circuit Then reset the breaker by moving the switch to Interrupter), which is an extremely sensitive...

  • Page 62: Electrical Generator

    SECTION 6 – ELECTRICAL ELECTRICAL GENERATOR –If Equipped WARNING Careless handling of the generator and electrical components can be fatal. Never touch electrical leads or appliances when your hands are wet, or when standing in water or on wet ground. Do not attempt to repair the generator Automatic Power Transfer Box yourself.

  • Page 63: Operation Warnings And Cautions

    SECTION 6 – ELECTRICAL Operation Warnings and Cautions WARNING The exhaust of all internal combustion engines contains carbon monoxide (CO). This poisonous gas is colorless, odorless, tasteless, and lighter than air. The exhaust systems of both your motor home engine and your generator engine have Generator Start/Stop Buttons been installed with your safety in mind.

  • Page 64: House/Coach Battery Disconnect Switch

    SECTION 6 – ELECTRICAL Converter Always leave this switch ON while using the coach. See “Power Center.” NOTE: Some electronic displays and memory Chassis Battery functions may need to be reset after The chassis battery is used to operate the power has been reconnected.

  • Page 65: Battery Care

    SECTION 6 – ELECTRICAL The two best defenses against sulfating and insufficient charge are to: 1. Turn off the House/Coach Battery Disconnect switch to avoid parasitic discharge (the trickle discharge caused by directly connected components like propane gas detectors or digital clock displays, etc.) 2.

  • Page 66: Circuit Breakers And Fuses - House 12-Volt

    If your coach is going to be unoccupied for metal parts. Should the cable be ® two weeks or more, Winnebago Industries damaged, a short circuit could result in recommends disconnecting the chassis batteries personal injury or damage to equipment.

  • Page 67: Battery Charge Meter

    SECTION 6 – ELECTRICAL House 12V Breakers -Typical View Battery Charge Meter See related item under “Systems Monitor Panel” in Appliances section. Battery Boost Switch See Driving Your Motor Home section for information on the Battery Boost Switch. 6-11...

  • Page 69: Plumbing

    SECTION 7 – PLUMBING FRESH WATER SYSTEM The fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet, and water heater. Water may be supplied by either of two sources: • a fresh water tank and water pump located within the motor home;...

  • Page 70: Water Pump

    SECTION 7 – PLUMBING 2. Turn Fresh Water Valve to Normal position Water pressure regulators are commonly and turn the water pump switches OFF. available at most RV dealerships and many large retail discount or home supply centers. WATER PUMP When your coach is not connected to a city water supply, water is supplied from the fresh water tank by a water system demand pump.

  • Page 71: Ice Maker Water Filter

    SECTION 7 – PLUMBING 2. Turn water pump switch to “OFF” position. 3. Fill water tank. 4. Open all faucets, hot and cold. 5. Turn on water pump switch. 6. Close each faucet as it begins to deliver a steady stream of water (close cold water first). Leave hot water faucets on until they also deliver a steady stream of water.

  • Page 72: Disinfecting Your Fresh Water System

    SECTION 7 – PLUMBING DISINFECTING YOUR FRESH WATER SYSTEM To ensure complete disinfection of the potable water system, it is recommended that the following procedure be followed on a new system, one that has not been used for a period of time, or one that could have become contaminated.

  • Page 73: Shower Hose Vacuum Breaker

    SECTION 7 – PLUMBING (You may need to leave a hot water faucet open for some time to flush the water heater with clean water. You may also want to turn WARNING the water heater off until this is done to avoid wasting energy trying to heat “unused”...

  • Page 74: Exterior Shower/Wash Station

    SECTION 7 – PLUMBING Important “Don’ts” and allows water remaining in the hose to drain down. This is a normal function of the shower • Don't use facial tissue or regular toilet tissue in valve assembly and is not a leak or defect. the RV toilet.

  • Page 75: Dumping Holding Tanks

    SECTION 7 – PLUMBING See “Specifications” in Section 1 - • 1st - Pull Introduction for tank capacities for your model. Black Waste Tank Drain Dumping Holding Tanks Valve to drain 1. Remove sewage drain hose from holding tank Black Water compartment.

  • Page 76: Holding Tank Level Indicators

    SECTION 7 – PLUMBING When using a sewer hook-up, keep the dump valves closed until a tank becomes full or when preparing to leave the site. This keeps the solids in suspension, allowing them to be carried out with the liquids when the dump valve is opened. If the valve is left open, the liquids will drain off, leaving solids in the tank.

  • Page 77: Water Heater Bypass Valve

    SECTION 7 – PLUMBING Normal By-Pass Flow Mode Leave bypass valve handle in NORMAL FLOW position if draining water and blowing Siphon out waterlines. Place in BYPASS position ONLY Tube when using antifreeze solution in waterlines. WINTERIZING PROCEDURES You can winterize the water and plumbing Winterization system of your coach using one of the following Valve...
  • Page 78 SECTION 7 – PLUMBING 6. Drain Toilet. Press the toilet flush pedal and hold until water stops flowing in the toilet. Then turn water pump switch off. 7. Drain Optional Appliances. At this time, if your coach is equipped with an optional refrigerator ice maker, the waterlines for that must also be drained.
  • Page 79 A blow-out plug can be purchased Do not add automotive antifreeze or caustic chemicals such as bleach or ® ® at any Winnebago or Itasca dealer. laundry detergents into the toilet bowl or holding tanks. Although these products...
  • Page 80 SECTION 7 – PLUMBING Your coach is equipped with a manually • Twist the filter cartridge counter-clockwise operated waterline winterization system for your (left) about a quarter-turn and pull it down and convenience in winterizing fresh waterlines. out of the filter socket. The system features a winterization (diverter) NOTE: The water filter head has a built-in valve with an antifreeze siphon tube to draw non-...
  • Page 81 SECTION 7 – PLUMBING 8. Press the toilet flush pedal and hold until antifreeze begins flowing into the toilet. Leave small amount of antifreeze that remains in the bowl. When Done Adding RV Antifreeze 9. Turn water pump switch off. 10.

  • Page 82: Winterizing Optional Appliances

    SECTION 7 – PLUMBING Section 11 - Maintenance and Storage. WINTERIZING OPTIONAL APPLIANCES –If Equipped Winterizing Ice Maker 1. Drain coach waterlines. 2. Unscrew the water supply line from the bottom of the water inlet valve and drain any water left in the line. This connection is located in the refrigerator service compartment on the outside of the coach.

  • Page 83: Water System Drain Valve Locations

    SECTION 7 – PLUMBING WATER SYSTEM DRAIN VALVE LOCATIONS Model System Drain Valve Locations Waterlines Open exterior shower faucet and lay shower head on ground. Also, place the tip of your finger inside the city water connection and gently press the backflow valve (small “button”...
  • Page 84 SECTION 7 – PLUMBING Waterlines Inside utility compartment (passenger side rear compartment) and open exterior shower. Water Tank Large yellow-handled valve in utility compartment. Water Heater Drain plug on outside of coach behind service door. Use socket to remove drain plug. Water Heater In wardrobe cabinet.

  • Page 85: Entertainment

    SECTION 8 – ENTERTAINMENT FRONT TV IGNITION SWITCH DVD PLAYER INTERLOCK –If Equipped If your coach is equipped with a front overhead TV, it is plugged into a special electrical outlet with a built-in ignition switch interlock. The device allows the front overhead TV to operate only when the ignition key is in the Off or Accessory positions.

  • Page 86: Cd/Dvd Player

    SECTION 8 – ENTERTAINMENT • Press the SOURCE or INPUT button on the TV or TV remote to select INPUT 2 or AV2. NEXT • The TV screen will display the DVD player logo when the correct input is selected. ENTER •...

  • Page 87: Flip-Down Screen Video Players

    SECTION 8 – ENTERTAINMENT Play TV Through Stereo Speakers The players each contain auxiliary audio- video inputs for connection of a video game The exterior entertainment center TV is system or other audio-video equipment if connected to the video selection box, the rooftop desired.

  • Page 88: Bedroom Tv 12-Volt Master Power Switch

    SECTION 8 – ENTERTAINMENT automatically switch to DVD mode. The BEDROOM TV 12-VOLT screen will display the DVD logo and begin to MASTER POWER SWITCH read the disc. • The DVD may load directly to the main title/ –If Equipped menu screen or it may begin to play previews.

  • Page 89: Tv Antenna

    SECTION 8 – ENTERTAINMENT Lowering Antenna to Travel TV ANTENNA Position The TV antenna on your motor home can be Rotate antenna until pointer on directional easily raised, rotated a full 360° and lowered handle aligns with pointer on ceiling plate. from inside the vehicle by simply turning a crank or directional handle.

  • Page 90: Satellite Dish And Cable Tv Connections

    (if equipped). good TV reception. ® See your authorized Winnebago Industries To check the antenna amplifier, raise the dealer for proper installation and sealing of roof antenna, select a TV channel and rotate the mounted components.

  • Page 91: Tv Digital Satellite System - Manual

    SECTION 8 – ENTERTAINMENT Further Information TV DIGITAL SATELLITE See the Digital Satellite System user guide SYSTEM – MANUAL provided in your InfoCase for complete operating instructions. –If Equipped The Digital Satellite Television System EXTERIOR ENTERTAINMENT allows you to receive TV programs directly from satellite to your coach.
  • Page 92 SECTION 8 – ENTERTAINMENT Exterior Entertainment Center -Typical View Further Information Please read the manufacturer’s user guide in your InfoCase for complete operating instructions.

  • Page 93: Furniture And Softgoods

    SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR – SWIVEL GLIDER –If Equipped This chair is not equipped with a seat belt and is not intended for seating while the vehicle is in motion. While the vehicle is in motion, the glide-lock mechanism must be in the locked position and the base of the lounge chair must be fastened to the Lounge Chair Glide Lock...

  • Page 94: Buffet Table And Chairs

    SECTION 9 – FURNITURE AND SOFTGOODS 2. Bind chairs together with the provided strap, BUFFET TABLE AND CHAIRS ensuring the strap goes through the ring –If Equipped located om the bottom side of the buffet table. (Typical view – your coach may differ according to floorplan) Buffet Chairs The buffet chairs are free-standing to allow...

  • Page 95: Sleeping Facilities

    SECTION 9 – FURNITURE AND SOFTGOODS SLEEPING FACILITIES WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion. DINETTE/BED CONVERSION 3. Rotate lock rod counter-clockwise (right) to (Dream Dinette Table secure table in the lowered position.

  • Page 96: Sofa/Bed Conversion

    SECTION 9 – FURNITURE AND SOFTGOODS Reverse steps to convert back into dinette seating. Security Latch Handle SOFA/BED CONVERSION (Shown with sofa seat lifted) -If Equipped - Press DOWN to release Sofa to Bed • Lift the front edge of the sofa seat upward and •...
  • Page 97 SECTION 9 – FURNITURE AND SOFTGOODS 2. Using the pull strap (attached to the back side of the sofa), pull the sofa back out and extend 4. Unfold the bottom section of the sofa air bed all the way down to the floor. and extend all the way down to the floor.
  • Page 98 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: The air mattress is plugged into an AC power outlet behind the sofa. It may be necessary to press the “Reset” button on the galley GFCI outlet before operating. 6. Press and Hold the INFLATE button on the hand control to fill the air mattress.
  • Page 99 SECTION 9 – FURNITURE AND SOFTGOODS 4. Rotate the lever lock “counter-clockwise”, 2. Fold in the bottom section of the air mattress. securing the bottom section of the sofa bed back into locked position. NOTE: Leaving the Deflation Valve open while converting back into sofa position will help remove any remaining air for more compact storage.

  • Page 100: Extendable Sectional Sofa

    SECTION 9 – FURNITURE AND SOFTGOODS Further Information See the air bed manufacturer’s user guide 2. Fully extend the sectional extension. provided in your InfoCase for complete air bed operating instructions, safety precautions, and repair information. EXTENDABLE SECTIONAL SOFA –If Equipped Your coach may be equipped with an Extendable Sectional Sofa, which converts easily into additional seating space.

  • Page 101: Roller Shades (Manual) - Solar Day/Night

    CABINETRY –If Equipped People are drawn to the natural beauty of ® wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the Winnebago Industries warranty.
  • Page 102 No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.

  • Page 103: Slideout Rooms And Leveling

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Release SLIDEOUT ROOM TRAVEL • Press and Hold the UNLOCK side of the LOCKS - ELECTRIC Slideout Room Lock switch for about 7 –If Equipped seconds. (You may be able to hear the lock motor sound stop).

  • Page 104: Slideout Room Travel Lock

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING NOTICE Release and remove Slideout Prop-Lock Rod before attempting to extend slideout room. Damage to the vehicle will result if this is not done. Position and secure Prop-Lock before driving vehicle. See following instructions. To Release Lock Rod Slideout Lock Drain Line •...

  • Page 105: Slideout Room Operation - Electric

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Master Keylock SLIDEOUT ROOM OPERATION A master keylock switch is located near the – ELECTRIC power switch for the front slideout room. This keylock must be turned on to provide power to the slideout control switches. WARNING Your motor home may have more than one slideout room.
  • Page 106 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Extend Procedure: NOTE: We recommend that you KEEP THE ENGINE RUNNING WHILE See “Before Extending!” before proceeding. EXTENDING OR RETRACTING • Start the engine so the alternator can provide SLIDEOUT ROOMS so the engine maximum power for proper operation of alternator can provide maximum power slideout mechanisms.

  • Page 107: Slideout Room - Extreme Weather Precaution

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING If it has rained recently before you retract the slideout room cover-awning (if equipped) or slideout room, we recommend using the reduce effectiveness of the slideout room weather hydraulic leveling system (if equipped) to lean seals.
  • Page 108 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Problems Retracting the Room retraction method or the fully manual method. Both methods listed below are intended as a • Set the Park Brake if the Engage Park Brake means to retract the room to prepare the coach for light flashes while pressing the Retract (IN) travel to the nearest authorized service center.

  • Page 109: Slideout Emergency Retraction - Electric

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Problems Extending the Room Further Information See the slideout room operating guide • Set the Park Brake if the Engage Park Brake included in your InfoCase for further instructions light flashes while pressing the Extend (OUT) and troubleshooting information.

  • Page 110: Slideout Emergency Retraction - Bedroom

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING Further Information 3) Use 3/4”socket on gearbox See the Slideout Room operating guide shaft to crank room in included in your InfoCase for further instructions and troubleshooting information. SLIDEOUT EMERGENCY RETRACTION - BEDROOM -If Equipped If the slideout mechanism is malfunctioning and the room will not retract using the interior...

  • Page 111: General Slideout Care

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING GENERAL SLIDEOUT CARE 1) Lift tab inside protrusion on boot to • Wipe outer seals occasionally with talc or 303 disengage motor brake brand protectant for smooth quiet operation. • Clean the floors inside before retracting the room to avoid floor scratches or carpet pile snags.
  • Page 112 SECTION 10 – SLIDEOUT ROOMS AND LEVELING while in PARK, raising either one or both These switches allow you to extend or retract of the rear wheels off the ground could your jacks and observe them at the same time. It allow the vehicle to roll off the jacks.

  • Page 113: Checking Hydraulic Oil Level

    SECTION 10 – SLIDEOUT ROOMS AND LEVELING 4. See the Leveling System user guide supplied in your InfoCase for troubleshooting instructions or operating the Leveling System if jacks fail to retract or any other functions fail. Further Information See the manufacturer’s user guide provided in your InfoCase for complete operating “Jacks Down”...
  • Page 114 SECTION 10 – SLIDEOUT ROOMS AND LEVELING The oil level should be between the two marks on the breather cap dipstick shown in the following photo. Hydraulic Oil Hydraulic Oil FULL Level Level ADD Mark Hydraulic Oil Breather Cap/Dipstick -Typical View NOTE: Overfilling the hydraulic reservoir can cause leakage of oil through the breather cap.

  • Page 115: Maintenance And Storage

    • Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.

  • Page 116: Exterior Automotive Paint Finish

    SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
  • Page 117 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.

  • Page 118: Care Of Appliques And Decals

    SECTION 11 – MAINTENANCE AND STORAGE is subjected to various twisting and flexing forces • Fuel or antifreeze spilled on appliques or caused by routine cornering and turning, and by decals should be rinsed off immediately with uneven road surfaces, such as bumps, potholes, water.

  • Page 119: Interior Soft Goods

    SECTION 11 – MAINTENANCE AND STORAGE • Kerosene or gasoline • Naphthalene WARNING • Pine-type household cleaners Do not use cleaners containing the following When cleaning upholstery and fabric, do products, compounds ,or solvents. These not use lacquer thinner, nail polish products will damage the finish.

  • Page 120: Cabinetry - Cleaning

    SECTION 11 – MAINTENANCE AND STORAGE Vinyl simulated wood panels may be cleaned with a mild, water-based cleaner and a soft cloth. UltraLeather Cleaning Chart Do not use solvents on vinyl wood panels. Detergent/ Cleaner/ Type of Stain Water Degreaser NOTE: Many cabinetry and furniture items Coffee, Tea throughout this motor home are...

  • Page 121: Galley Sink

    SECTION 11 – MAINTENANCE AND STORAGE Scale • Do not use wool, abrasive brushes, or tools that have previously cleaned other metals, To remove scale left by water, simply use a because as well as scratching the surface, they multipurpose cream detergent and a soft cloth. can generate contamination and unattractive Thicker scale may be removed by generously stains.

  • Page 122: Range And Refrigerator

    SECTION 11 – MAINTENANCE AND STORAGE Lavatory Sink - Acrylic NOTE: Improper use may damage this product and void the warranty. General Cleaning Clean often with hot water and soap. If a RANGE AND REFRIGERATOR cleanser is necessary, make sure the product is recommended for use on plastics.

  • Page 123: Vehicle Storage - Removal

    SECTION 11 – MAINTENANCE AND STORAGE Clean and Prep Coach for Storage 9. Inspect all seams and seals around doors, windows, vents, and any other joints. Replace 1. Turn off the propane gas tank. or repair any that are damaged. Sealing 2.

  • Page 124: Chassis Service And Maintenance

    SECTION 11 – MAINTENANCE AND STORAGE system (if equipped). See appropriate filter NOTE: Before turning the water supply on, installation instructions in Section 7 - assure that the water faucet filter is in Plumbing. place and that the water shut-off valve (typically located inside galley cabinet NOTE: Always purge a new filter with clean beneath sink) is OPEN.

  • Page 125: Coach Maintenance Chart

    SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System Have propane gas system checked for leaks Pressure Regulator - inspect and adjust if needed Check propane tank condition, mounting, and fittings...
  • Page 126 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: Headlights, Taillights, and Marker Lights Turn Signals...
  • Page 127 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants Inspect (see “Sealants”...

  • Page 129: Miscellaneous

    SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
  • Page 130 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...

  • Page 131: Car Or Trailer Towing

    SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual listed Gross Weight Ratings. See “Vehicle set (left rear duals or right rear duals) should not Certification Label” in the Introduction section exceed 6,000 lbs. for information on gross weight ratings.

  • Page 132: Trailer Wiring Connector

    SECTION 12 – MISCELLANEOUS Before descending a steep or long grade when TRAILER WIRING towing a trailer, reduce speed and shift into a CONNECTOR lower gear to control vehicle speed. Avoid prolonged or frequent application of brakes Your coach is pre-wired for trailer or car which could cause overheating and brake failure.

  • Page 133: Fireplace

    350 vehicle drive train: engine and cooling systems, lbs. All Winnebago Industries models transmission, drive line, drive axle, and others. equipped with a Class IV hitch have a...

  • Page 134: Entry Step - Electric

    SECTION 12 – MISCELLANEOUS For additional heat, turn Thermostat Control knob CLOCKWISE until you hear the “click” again to turn the heater on. Turn the Thermostat Control knob fully COUNTER-CLOCKWISE to turn the heater off. NOTE: The heater unit is protected with a safety device to prevent overheating.

  • Page 135: Windows

    SECTION 12 – MISCELLANEOUS Stationary Extended Mode - Step Switch OFF (Step Remains Extended) With the Step power switch in the OFF position, the step will extend when the screen door is opened and will stay extended whether the door is opened or closed. NOTE: The step switch is “locked”...

  • Page 136: Power Roof Ventilator

    SECTION 12 – MISCELLANEOUS Manual Dome Fuse Fan Speed Crank Knob Selector Vertical Slider Windows Vertical windows have spring-loaded catches on both sides of the window that pop out to hold the window in its fully raised position. Press the catches outward toward the frames while lowering the window.

  • Page 137: Power Awning

    SECTION 12 – MISCELLANEOUS Further Information Further Information See the power ventilator manufacturer’s For complete operating instructions, features, operating instructions supplied in your InfoCase safety precautions, and maintenance care, refer to for further instructions, care, and cleaning the awning manufacturer’s information provided information.

  • Page 138: Tool And Ladder Storage

    SECTION 12 – MISCELLANEOUS Before Using the Ladder • Inspect the ladder to make sure it is not damaged. Never use a damaged ladder. • Keep the rungs of the ladder clean and dry while in use. Never use the ladder when it is raining, snowing, or icy.

  • Page 139: Humidity And Condensation

    SECTION 12 – MISCELLANEOUS Humidity and Condensation Moisture condensing on the inside of windows is a visible indication that there is too much humidity inside the coach. Excessive moisture can cause water stains or mildew, which can damage interior items such as upholstery and cabinets.
  • Page 141 INDEX 12-Volt Front Drop-Down Solar/ Drainage System (P-Traps) ......7-6 Night Shade ..........3-5 Driving Safety ..........2-1 2011 New Vehicle Limited Warranty ..1-7 Ducted Roof Air Conditioning System ..4-10 About this Manual ........1-1 DVD Player ..........8-1 Air Conditioner/Heater –...
  • Page 142 Index House/Coach Battery Disconnect Switch ..6-8 Rearview Monitor System ......3-4 Ice Maker ............. 4-2 Refrigerator ..........4-1 Ice Maker Water Filter ......... 7-3 Refrigerator Service Access Compartment .. 4-2 Interior Soft Goods ........11-5 Reporting Safety Defects ......1-2 Inverter Unit –...
  • Page 143 Index TV Digital Satellite System – Manual ..8-7 TV Digital Satellite System Wiring ..... 8-6 TV Signal Amplifier ........8-5 Undercarriage ..........11-1 Vehicle Certification Label ......1-4 Vehicle Storage – Preparation ....11-8 Vehicle Storage – Removal ....... 11-9 Vinyl Flooring ..........

Table of Contents