Table of Contents
Advertisement
Appendix A - Maintenance
Maintenance Procedures
The following maintenance procedures should be performed on a routine basis:
Drain the unit's fuel reservoirs and replace the fuel filters after every 30 cleaning services for
1.
Gasoline (Petrol), or every 10 cleaning services for the unit's diesel fuel reservoir for
maximum performance as described in the next section.
Clean the exterior with a non-abrasive cleaning agent or similar product to keep the cabinet
2.
looking new. Check the cabinet for dents or impact markings.
Check all hoses and wires for cuts or frays.
3.
Replacing the MCS 352 Fuel Filters
The unit's gasoline (petrol) fuel reservoir should be drained and the fuel filter replaced after
every 30 cleanings to ensure maximum system performance and pump life. The unit's diesel
fuel reservoir should be drained and the fuel filter replaced every 10 cleanings for maximum
performance.
Drain the Fuel Reservoir
Turn the
1.
SERVICE SELECTOR
On the
2.
Gasoline (Petrol)
clockwise until it is completely closed.
Attach the unit to the vehicle's battery by connecting the
3.
battery terminal and the
possible. Turn on the
Connect the #060-1400 adaptor to the output (
4.
unit's fuel reservoir using the following procedure:
•
Set the
TIMER
•
Direct the output (
•
Press and hold the
the container.
•
Release the
•
On the
Gasoline (Petrol)
completely open to relieve any residual pressure.
Enter your initials, the date, and a check mark in the appropriate boxes of the Maintenance
5.
Record in the Operators Manual.
switch to either
side, turn the
battery clip to a solid ground point as far from the battery as
black
switch.
ON/OFF
until it displays five minutes.
) hose into an appropriate container.
red
switch until the fuel from the unit has been emptied into
START/RUN
switch.
START/RUN
side, turn the
Gasoline (Petrol) or Diesel FUEL SYSTEM.
PRESSURE REGULATOR
red
) hose, then drain the fuel from the
red
PRESSURE REGULATOR
on the control panel
battery clip to the positive (
counterclockwise until
)
+
Advertisement
Table of Contents
