Table of Contents
Advertisement
P/N 126736-01 Rev. B 03/2014
.
P126736-01
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile
home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the
rating plate. This appliance is not convertible for use with other gases, unless a certified kit is used.
WARNING AVERTISSEMENT AVISO
HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
WARNING: If the information in these
instructions is not followed exactly, a fire or
explosion may result causing property damage,
personal injury or death.
— Do not store or use gasoline or other
flammable vapors and liquids in the vicinity
of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Immediately call your gas supplier from
a neighbor's phone. Follow the gas
supplier's instructions.
• If you cannot reach your gas supplier, call
the fire department.
— Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
Installation and Operation Instructions
Superior™ Custom Series Decorative B-Vent Fireplace
Millivolt System
PFS
Models
®
BRT4036TMN
C
US
BRT4336TMN
BRT4536TMN
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour consultation ultérieure.
UNE SURFACE VITRÉE CHAUDE PEUT
CAUSER DES BRÛLURES.
LAISSER REFROIDIR LA SURFACE VITRÉE
AVANT D'Y TOUCHER.
NE PERMETTEZ JAMAIS À UN ENFANT DE
TOUCHER LA SURFACE VITRÉE.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incindie ou d'explosion ou pour éviter
tout dommage matériel, toute blessure ou la mort.
— Ne pas entreposer ni utilizer d'essence ni d'autres
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
— QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous
servir des téléphones se trouvant dans le bâtiment
où vous trouvez.
• Appelez immédiatement votre fournisseur de
gaz depuis un voisin. Suivez les instructions du
fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
— L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
BRT4042TMN
BRT4036TMP
BRT4342TMN
BRT4336TMP
BRT4542TMN
BRT4536TMP
EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
USTED DEBE NUNCA TOCAR
EL VIDRIO CALIENTE.
LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.
BRT4042TMP
BRT4342TMP
BRT4542TMP
Advertisement
Table of Contents
Related Manuals for Superior BRT4036TMN
Summary of Contents for Superior BRT4036TMN
- Page 1 Installation and Operation Instructions Superior™ Custom Series Decorative B-Vent Fireplace Millivolt System P/N 126736-01 Rev. B 03/2014 Models ® BRT4036TMN BRT4042TMN BRT4036TMP BRT4042TMP BRT4336TMN BRT4342TMN BRT4336TMP BRT4342TMP BRT4536TMN BRT4542TMN BRT4536TMP BRT4542TMP P126736-01 INSTALLER: Leave this manual with the appliance. Installateur : Laissez cette notice avec l’appareil.
-
Page 2: Table Of Contents
WARNING: Improper installation, adjustment, al- teration, service or maintenance can cause injury or property damage. Refer to this manual for correct in- stallation and operational procedures. For assistance or additional information consult a qualified installer, service agency or the gas supplier. NOT FOR USE WITH SOLID FUEL CHECK LOCAL CODES PRIOR TO INSTALLATION SAVE THIS BOOK... -
Page 3: Safety
SAFETY 1. This appliance is only for use with the type WARNING: This product con- of gas indicated on the rating plate. This tains and/or generates chemicals appliance is not convertible for use with other gases unless a certified kit is used. known to the State of California 2. -
Page 4: Unpacking
• Three (3) plastic bags containing lava rock, Safely retain these items for later installation. pan and ember materials INTRODUCTION Models BRT4036TMN, 4336TMN, 4536TMN, completely. 4042TMN, 4342TMN, 4542TMN, 4036TMP, This INNOVATIVE HEARTH PRODUCTS ap- 4336TMP, 4536TMP, 4042TMP, 4342TMP,... -
Page 5: Selecting Location
INTRODUCTION Continued other than instructed in this manual. NOTICE: Decorative product D) Burning of anything other than the type of not for use as a heating ap- gas approved for use in this gas appliance. pliance. The installation must conform with local codes or, in the absence of local codes, with the current National Fuel Gas Code, ANSI The appliance and it’s individual shutoff valve... -
Page 6: Product Specifications
PRODUCT SPECIFICATIONS GAS RATING - NATURAL BRT4036TMN, BRT4042TMN, 4336TMN, 4536TMN 4342TMN, 4542TMN Max. Input Rating: 40,000 Btu/Hr 45,000 Btu/Hr Manifold Pressure: 3.5" WC (.87 kPa) 3.5" WC (.87 kPa) Minimum Supply Pressure: 4.5" WC (1.12 kPa) 4.5" WC (1.12 kPa) Maximum Supply Pressure: 10.5"... -
Page 7: Pre-Installation Preparation
2 x 4 Stud Nailing 3" (7.6 cm) Flange " Left Side Back (3.8 cm) Max. Surround 0 cm/po Clearance BRT4036TMN/TMP, BRT4042TMN/TMP, BRT4336TMN/TMP, BRT4342TMN/TMP, 0 cm/ BRT4536TMN/TMP BRT4542TMN/TMP 14" (35.6 cm) 15" (38 cm) 8" (20.3 cm) 9" (22.9 cm) - Page 8 " above the bottom of the appliance. The at Nailing Flanges gas line must be installed through the lower left side access point or alternate access BRT4036TMN, 4336TMN, BRT4042TMN, 4342TMN, 4536TMN, 4036TMP, 4542TMN, 4042TMP, hole in the bottom of the appliance (see...
-
Page 9: Requirements For The Commonwealth Of Massachusetts
REQUIREMENTS FOR THE COMMONWEALTH OF MASSACHUSETTS INSPECTION For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or The state or local gas inspector of the side structure used in whole or in part for residential wall horizontally vented gas fueled equipment purposes, including those owned or operated by shall not approve the installation unless, upon... -
Page 10: Venting Installation
VENTING INSTALLATION A B-type venting system must be connected 60° or greater. The total vertical height in this to the appliance for venting to the outside of example represents the minimum height of 8 the building. feet and therefore the allowable lateral is 6 feet when the 75% rule applies. - Page 11 VENTING INSTALLATION Continued CHECKING FOR PROPER VENTING Some codes areas allow the use of existing B-type vent systems if the system is at or After completing and checking electrical, above the recommended diameter of the flue, gas and vent connections, follow the lighting in this case 6".
-
Page 12: Installation
INSTALLATION WALL SWITCH INSTALLATION The installation of a wall switch allows you to activate the gas control valve without normal household electricity since valve operates on millivolt current supplied by heat generated by the thermopile. To install wall switch: 1. Remove front refractory access panel by lifting up and angling out of firebox opening (see Figure 13). - Page 13 7" In conformance with local codes, route a 7" 1/2" NPT gas line to appliance through hole Alternate Gas Supply Through Sub-Floor in left side of firebox or sub-floor as shown BRT4036TMN/TMP, BRT4042TMN/TMP, in Figure 16. BRT4336TMN/TMP, BRT4342TMN/TMP, BRT4536TMN/TMP BRT4542TMN/TMP CAUTION: Do not kink flex- "...
- Page 14 INSTALLATION Continued Complete your gas installation by connect- CAUTION: Compounds used ing incoming gas line with flexible gas line. Secure tightly with wrench but DO NOT on threaded joints of gas piping OVERTIGHTEN. shall be resistant to the action of Liquefied Petroleum (LP or EMBER AND PAN MATERIAL propane) and should be applied PLACEMENT...
- Page 15 INSTALLATION Continued Grate Pan and Ember NOTICE: Do not put lava rock in- Material 0.5" side burner pan or around the air mixer fitting. Placing lava rock inside burner pan or blocking openings of the propane/LP air- 0.5" mixer could cause performance problems.
- Page 16 INSTALLATION Continued LOG PLACEMENT FOR BRT4042, 5. Place upper end of log 5 into notch on top inner right of log 1 (see Figure 28). Rest BRT4342 AND BRT4542 MODELS lower end of log 5 on middle grate finger 1. Place large back log (log 1) onto grate as shown in Figure 29.
- Page 17 INSTALLATION Continued COMBUSTION AIR KIT MODEL AK4 INSTALLING OPTIONAL GLASS (OPTIONAL) DOOR ACCESSORY The outside air kit may be installed on the left CAUTION: Use only glass side of fireplace only. The vent can be installed doors certified for use with this through any outside wall a minimum of three feet below fireplace termination cap.
- Page 18 INSTALLATION Continued 6. Repeat the process for the opposite door Spring Hold-Down Clip assembly. Screw 7. To adjust doors, slide them partially open. Side Using a screwdriver, loosen hold-down Front screws in the spring clip (see Figure 33) Face and pivot plate. 8.
-
Page 19: Operation
OPERATION FOR YOUR SAFETY 1. STOP! Read the safety information, col- umn 1. READ BEFORE LIGHTING 2. Turn wall switch to the OFF position. WARNING: If you do not fol- 3. Turn off all electric power to appliance. low these instructions exactly, 4. -
Page 20: Inspecting Burners
OPERATION Continued TO TURN OFF GAS crease the flame to proper size (see Figure 36, page 19). Do not remove adjustment TO APPLIANCE screw. 1. Turn off wall switch. • see Troubleshooting, page 23 2. Turn off all electric power to appliance if service is to be performed. -
Page 21: Cleaning And Maintenance
CLEANING AND MAINTENANCE WARNING: Installation and WARNING: Failure to keep repair should be done by a quali- the primary air opening(s) of fied service person. The appli- the burner(s) clean may result in ance should be inspected before sooting and property damage. each use and at least annually by a qualified service person. -
Page 22: Wiring Diagram
WIRING DIAGRAM PILOT BURNER THERMOPILE REPLACE FACTORY WIRING WITH 105°C IGNITOR EQUIVALENT OR HIGHER RATING EXTERNAL WIRING USE ONLY CLASS 2 THERMOSTAT WIRE 18 GA. RED/WHITE PILOT GAS LINE DO NOT CONNECT TO 120V WHITE N.O. SW N.C.SW MANUAL DAMPER TH/TP SWITCH INCOMING... -
Page 23: Troubleshooting
TROUBLESHOOTING Note: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging pilot and/or gas control valve filter OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Pilot will not light... - Page 24 TROUBLESHOOTING Continued OBSERVED PROBLEM POSSIBLE CAUSE REMEDY Pilot goes out when wall switch 1. Millivolt output on thermo- 1. Replace thermopile is ON pile too high Spark ignitor will not light pilot 1. Defective ignitor (no spark 1. Check for spark at electrode after repeated triggering of at electrode) and pilot.
- Page 25 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Fol- low the gas supplier’s instructions.
-
Page 26: Parts
PARTS MODELS BRT4036TMN, 4336TMN, 4536TMN, 4042TMN, 4342TMN, 4542TMN, 4036TMP, 4336TMP, 4536TMP, 4042TMP, 4342TMP, 4542TMP 35 34 (Back) www.SuperiorFireplaces.US.com 126736-01B... - Page 27 PARTS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on page 22 of this manual. NO. 36" Models 42" Models DESCRIPTION 14153 14153 Micro Switch 11165 11165 Screw, #10 x 5/8 Mod. Tr. Blk. Ox 110037-01 110037-01 Electrical Duct Assembly 22912 22924...
- Page 28 PARTS BRICK LINERS FOR MODELS BRT4036TMN, 4336TMN, 4536TMN, 4036TMP, 4336TMP, 4536TMP NO. 36" Models 42" Models DESCRIPTION 106658-02 107812-02 Left Refractory, Std. Brick (4336TMN/P, 4342TMN/P) 108164-02 108169-02 Left Refractory, Herringbone (4536TMN/P, 4542TMN/P) 106659-02 107814-02 Right Refractory, Std. Brick (4336TMN/P, 4342TMN/P)
- Page 29 PARTS LOGSETS FOR MODELS BRT4036TMN, 4336TMN, 4536TMN, 4036TMP, 4336TMP, 4536TMP PART NUMBER DESCRIPTION QTY. 107999-01 Log Set 108724-01 Right Front 9" Split Log 901098-01 Rear Log 108720-01 Top Right Log - 11 " 108721-01 Top Right Log - 16" 108722-01 Top Left Log - 13 "...
- Page 30 PARTS LOGSETS FOR MODELS BRT4042TMN, 4342TMN, 4542TMN, 4042TMP, 4342TMP, 4542TMP PART NUMBER DESCRIPTION QTY. 107999-02 Log Set 901098-02 Rear Log 108723-01 Left Front Log - 11" 108839-01 Right Front Log - 15 " Round 108722-01 Top Left Log - 13 "...
-
Page 31: Accessories
ACCESSORIES NOTICE: All accessories may not be available for all fireplace models. Purchase these accessories from your local dealer. If they can not supply these accessories call INNOVATIVE HEARTH PRODUCTS at 1-800-655-2008 for information. You can also write to the address listed on the back page of this manual. AIR KIT - AK4 BRICK LINER KIT Optional kit helps offset the negative pressure... -
Page 32: Warranty
THE WARRANTY Innovative Hearth Products ("IHP") 20 Year Limited Warranty warrants your Superior™ Brand gas fireplace, Stove or Insert ("Product") to be free from defects in materials and workmanship at the time of manufacture. The Product body and firebox carry the 20 Year Limited Warranty. Ceramic glass carries the 20 Year Limited Warranty against thermal breakage only. - Page 33 KEEP THIS WARRANTY Model (located on product or identification tag) _____________________________ Serial No. (located on product or identification tag) __________________________ Date Purchased __________________________ Keep receipt for warranty verification. www.SuperiorFireplaces.US.com 126736-01B...
- Page 34 NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ www.SuperiorFireplaces.US.com 126736-01B...
- Page 35 NOTES _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ www.SuperiorFireplaces.US.com 126736-01B...
- Page 36 Innovative Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. 1508 Elm Hill Pike, Suite 108 P126736-01 Nashville, TN 37210 1-800-655-2008...