Table of Contents
Advertisement
Quick Links
P/N 126745-01 Rev. E 02/2018
P126745-01
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future
reference.
This appliance may be installed in an aftermarket permanently located, manufactured home (USA only)
or mobile home, where not prohibited by local codes. This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not convertible for use with other gases, unless a certified kit
is used.
Cet appareil peut installé dans une maison préfabriquée (mobile) déjà installée à demeure, si les réglements
locaux le permettent. Ce appareil doit être utilisé uniquement avec le type de gaz indiqué sure la plaque
signalétique. Cet appareil ne peut être converti à d'autres gaz, sauf si une trousse de conversion est utilsée.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use
any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a neigh-
bor's phone. Follow the gas supplier's instruc-
tions.
• If you cannot reach your gas supplier, call the
fire department.
- Installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
Installation and Operation Instructions
B-Vent Gas Decorative Fireplace
Models
C
US
Report No. F09-157
Installateur : Laissez cette notice avec l'appareil.
Consommateur : Conservez cette notice pour
consultation ultérieure.
RISQUED'INDENDIE OU D'EXPLOSION
Le non-respect Des avertissements de sécurité
pourrait d'entraîner des blessures graves, la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir
• Sortez immédiatement de bâtiment.
• Appelez immédiatement votre fournisseur de
• Si vous ne pouvez rejoindre le fournisseur de gaz,
- L'installation et l'entretien doivent être assurés par
BRT2032TMN BRT2332TMN BRT2532TMN
AVERTISSEMENT:
vapeurs ou liquides inflammables dans le voisinage
de cet appareil ou de tout autre appareil.
des téléphones se trouvant dans le bâtiment où
vous trouvez.
gaz depuis un voisin. Suivez les instructions du
fournisseur.
appelez le service des incindies.
un installateur ou un service d'entretien qualifié
ou par le fournisseur de gaz.
Advertisement
Table of Contents
Related Manuals for Superior BRT2032TMN
Summary of Contents for Superior BRT2032TMN
- Page 1 Installation and Operation Instructions B-Vent Gas Decorative Fireplace Models P/N 126745-01 Rev. E 02/2018 BRT2032TMN BRT2332TMN BRT2532TMN Report No. F09-157 P126745-01 INSTALLER: Leave this manual with the appliance. Installateur : Laissez cette notice avec l’appareil. CONSUMER: Retain this manual for future Consommateur : Conservez cette notice pour reference.
-
Page 2: Table Of Contents
Thank you for your purchase. We appreciate your business! Please carefully read and follow all instructions in this manual. Pay special attention to all warnings and safety information. Following these safety, care, and operation instructions will help ensure many years of dependable and enjoyable service from your fireplace. Please read and understand these instructions before installing or operating. - Page 3 SAFETY Continued This fireplace is a vented product. This fireplace will not produce 6. Carefully supervise young children when they are in the room any gas leakage into your home if properly installed. This fireplace with fireplace. must be properly installed by a qualified service person. If this 7.
-
Page 4: Unpacking
UNPACKING This INNOVATIVE HEARTH PRODUCTS (IHP) appliance and its ap- proved components are safe when installed according to this instal- The following items are packed inside the firebox. Remove before lation manual and are operated as recommended by IHP. Using any positioning firebox into framing. -
Page 5: Product Specification
PRODUCT SPECIFICATION GAS RATING - NATURAL BRT2032TMN BRT2332TMN AND BRT2532TMN Max. Input Rating 15,000 Btu/Hr 25,000 Btu/Hr Manifold Pressure 3.5" WC (0.87 kPa) 3.5" WC (0.87 kPa) Minimum Supply Pressure 4.5" WC (1.12 kPa) 4.5" WC (1.12 kPa) Maximum Supply Pressure 10.5"... -
Page 6: Selecting Location
SELECTING LOCATION To determine the safest and most efficient location for your appliance, Flush installations are recommended where living space is limited or you must take into consideration the following guidelines: at a premium, and since the space required to enclose the appliance would be located beyond an outside wall, this would also reduce the 1. -
Page 7: Pre-Installation Preparation
PRE-INSTALLATION PREPARATION CLEARANCES MANTEL CLEARANCES AND WALL DETAILS Minimum clearances to combustibles are: Ceiling 40" min. A combustible mantle shelf maybe installed a maximum 12" (22.9 cm) from the wall. Figures 5 and 6 show the minimum allowable Top of Spacers 0"... - Page 8 PRE-INSTALLATION PREPARATION Continued FRAMING NOTE: If 1/2" NPT black iron pipe does not mate with fitting at the end of flexible gas line, remove fitting and replace with a 37 1. Frame appliance enclosure as illustrated in Figures 7 and 8. degree flare 3/4"-12, 1/2"...
-
Page 9: Requirements For The Commonwealth Of Massachusetts
COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS These appliances are approved for installation in the US state of Massachusetts if the following additional requirements are met: • Install this appliance in accordance with Massachusetts Rules and Regulations 248 C.M.R. Sections 4.00 through 8.00. •... -
Page 10: Venting Installation
VENTING INSTALLATION A B-type venting system must be connected to the appliance for Example 2 shows a multiple offset each at 45° of inclination. Multiple venting to the outside of the building. offsets are permitted if they do not exceed 45° of inclination. The total lengths of the two offsets are not required to meet the 75% IHP defines installation standards of this product. - Page 11 VENTING INSTALLATION Continued CHECKING FOR PROPER VENTING Lowest Listed Discharge After completing and checking the electrical, gas and vent connec- Vent Cap Opening tions, follow the lighting instructions and allow the main burner to run for approximately 5 minutes. Hold a lit match or cigarette near 8 Ft.
-
Page 12: Fireplace Installation
FIREPLACE INSTALLATION WALL SWITCH INSTALLATION OPTIONAL WIRELESS HAND-HELD REMOTE CONTROL INSTALLATION Installation of a wall switch allows you to activate gas control valve without normal household electricity since the valve operates on NOTE: If using optional wireless hand-held remote control, the wall millivolt current supplied by heat generated by thermopile. - Page 13 FIREPLACE INSTALLATION Continued Incoming IHP recommends that a black iron gas line be routed from the gas 1/2" Gas Line source, through a sediment trap (shown in Figure 16), and into ap- pliance. Once connected through appliance, a flexible gas line may Permitted by be used for ease of installation to gas control valve (see Figure 17).
- Page 14 The grate must be placed in the burner pan so that the back grate fingers Grate (BRT2332TMN/BRT2532TMN) or pins (BRT2032TMN) fit into the notches on back of burner pan and front legs fit inside burner pan as shown in Figure 18.
- Page 15 FIREPLACE INSTALLATION Continued Top Left Rear Log Right Front Left Log Figure 23 - Installing Top Left and Right Logs Figure 25 - Installing Log 3 LOG PLACEMENT FOR BRT2332TMN AND BRT2532TMN MODELS Top Log 1. Place rear log onto grate making sure notches rest over grate (see Figure 24).
- Page 16 FIREPLACE INSTALLATION Continued COMBUSTION AIR KIT MODEL AK4 (OPTIONAL) INSTALLING OPTIONAL GLASS DOOR ACCESSORY The outside air kit may be installed on the left side of the fireplace CAUTION: Use only glass doors certified for use only. The vent can be installed through the outside wall or a ventilated crawl space.
- Page 17 FIREPLACE INSTALLATION Continued Doors may be removed for replacement or cleaning as follows: CAUTION: Glass panels become very hot while 1. Partially open door and press up on the upper spring clip with a the appliance is operating. Do not attempt to adjust screw driver until outer top pivot pin is free of clip.
-
Page 18: Operation
OPERATION LIGHTING FOR YOUR SAFETY READ BEFORE LIGHTING INSTRUCTIONS NOTICE: During initial operation of new fireplace, WARNING: If you do not follow these instructions burning logs will give off a paper-burning smell. exactly, a fire or explosion may result causing property Orange flame will also be present. - Page 19 OPERATION Continued TO TURN OFF GAS OPTIONAL HAND-HELD TO APPLIANCE REMOTE OPERATION NOTE: Receiver and hand-held remote control kit must be purchased 1. Turn off wall switch (if installed). separately (see Accessories, Page 23). Follow installation instructions 2. Turn off all electric power to appliance if service is to be per- included with the remote control.
-
Page 20: Inspecting Burners
(see Figure 33, Page 18). Do not remove adjustment screw. • see Troubleshooting, Page 21 Thermopile Pilot Burner (BRT2032TMN) Model Igniter Figure 35 - Correct Pilot Flame Pattern (BRT2332TMN/BRT2532TMN) Models Figure 36 - Typical Flame Pattern... -
Page 21: Troubleshooting
TROUBLESHOOTING NOTE: Before troubleshooting the system, make sure the gas shutoff valve is ON. The two most common causes of a malfunctioning gas appliance are: 1. Loose wiring connections 2. Construction debris clogging the pilot and/or gas control valve filter OBSERVED PROBLEM POSSIBLE CAUSE REMEDY... - Page 22 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply. • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. •...
-
Page 23: Replacement Parts
Cat.# F0995, Model FD32P - 32" Fixed Door, Platinum PERIMETER TRIM PROPANE/LP GAS CONVERSION KIT - BRT2032TMN Cat.# F1039, Model PT32 32" Perimeter Trim - Black Cat.# F1118, Model PCBM-324 - Millivolt - NG to LP Cat.# F1040, Model PT32B 32"... -
Page 24: Parts
PARTS MODEL BRT2032TMN CATALOG NO. MODEL F0851 BRT2032TMN 43 41 SuperiorFireplaces.us.com 126745-01E... - Page 25 PARTS MODEL BRT2032TMN This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 23 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
- Page 26 PARTS BRT2332TMN AND BRT2532TMN MODELS CATALOG NO. MODEL F0853 BRT2332TMN F0855 BRT2532TMN 33 43 SuperiorFireplaces.us.com 126745-01E...
- Page 27 PARTS BRT2332TMN (F0853) AND BRT2532TMN (F0855) MODELS This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 23 of this manual. WARNING: Contact an IHP dealer to obtain any of these parts. Never use substitute materials not approved by IHP.
- Page 28 BURNER ASSEMBLY This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 23 of this manual. BRT2032TMN (F0851) MODEL BRT2332TMN (F0853) AND BRT2532TMN (F0855) MODELS KEY NO. PART NO.
-
Page 29: Wiring Diagram
LOG ASSEMBLY This list contains replaceable parts used in your fireplace. When ordering parts, follow the instructions listed under Replacement Parts on Page 23 of this manual. BRT2332TMN (F0853) AND BRT2532TMN (F0855) MODELS BRT2032TMN (F0851) MODEL KEY NO. PART NO. DESCRIPTION QTY. - Page 30 NOTES ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ _____________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ ______________________________________________________ SuperiorFireplaces.us.com 126745-01E...
-
Page 31: Warranty
® 20 Year Limited Warranty THE WARRANTY Innovative Hearth Products ("IHP") 20 Year Limited Warranty warrants your Superior Brand gas fireplace, Stove or Insert ("Product") to be free from defects in materials ® and workmanship at the time of manufacture. The product body, firebox and barrier carry the 20 Year Limited Warranty. Ceramic glass carries the 20 Year Limited Warranty against thermal breakage only. - Page 32 SuperiorFireplaces.us.com Record the following important information about your fireplace: Fireplace model number Fireplace serial number Date fireplace was Installed Type of gas fireplace uses Dealer name Innovative Hearth Products (IHP) reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products.