Regency Plateau PTO30-NG Owners & Installation Manual

Plateau outdoor decorative gas appliance

Advertisement

Quick Links

Regency Plateau
Outdoor Decorative Gas Appliance
www.regency-fi re.com
WARNING:
If the information in these instructions
are not followed exactly, a fire
or explosion may result causing
property damage, personal injury or
loss of life.
WARNING:
Improper installation, adjustment,
alteration, service or maintenance
can cause injury or property damage.
Read the installation, operating and
maintenance instructions thoroughly
before installing or servicing this
equipment.
Installation and service must be
performed by a qualifi ed installer,
service agency or the gas supplier.
Tested by:
918-990a
FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4
PTO30 / PTO60
WARNING - FOR YOUR SAFETY
What to do if you smell gas:
•Shut off gas to the appliance.
•Do not try to light any appliance.
•Extinguish any open fl ame.
•If odour continues, keep away from the appliance and im-
mediately call your gas supplier or fi re department.
•Do not touch any electrical switch: do not use any phone
in your building.
•Immediately call your gas supplier from a neighbour's
phone.
•Follow the gas supplier's instructions.
•If you cannot reach your gas supplier, call the fi re
department.
WARNING:
Do not store or use gasoline or other fl ammable vapours
and liquids in the vicinity of this or any other appliance.
Installer: Please complete the details on the back cover
and leave this manual with the homeowner.
Homeowner: Please keep these instructions for future reference.
Installation Manual
Models: PTO30-NG / PTO30-LP
WARNING: FOR OUTDOOR USE ONLY
Owners &
PTO60-NG / PTO60-LP
07/19/11

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Plateau PTO30-NG and is the answer not in the manual?

Questions and answers

Summary of Contents for Regency Plateau PTO30-NG

  • Page 1 Owners & Regency Plateau PTO30 / PTO60 ™ Installation Manual Outdoor Decorative Gas Appliance Models: PTO30-NG / PTO30-LP PTO60-NG / PTO60-LP WARNING: FOR OUTDOOR USE ONLY www.regency-fi re.com WARNING: WARNING - FOR YOUR SAFETY If the information in these instructions...
  • Page 2 To the New Owner: Congratulations! ® You are the owner of a state-of-the-art Outdoor Decorative Gas Appliance by REGENCY . The Plateau™ PTO30 Outdoor decorative gas appliance has been designed to provide you with all the warmth and charm of a fi re at the fl ick of a switch. The Plateau™ PTO30 Outdoor Decorative Gas Appliance has been approved by Warnock Hersey/Intertek for both safety and effi...
  • Page 3: Table Of Contents

    Wiring Diagram ............15 PTO60 assembly ............16 PTO30 table top Installation ........17 PTO60 table top Installation ........18 Glass crystal installation on burner......19 Volcanic stone installation on burner ......20 Optional Log Set Installation........21 Optional glass surround Installation ......23 Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 4: Safety Label

    Commonwealth of Massachusetts. For the State of Massachusetts, fl exible connec- tors shall not exceed 36 inches in length. For the State of Massachusetts, the appliances individual manual shut-off must be a t-handle type valve. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 5: Dimensions

    12-13/16” (352mm) 6” (152mm) 18-9/16” (470mm) 37-15/16” (963mm) 41-1/2” (1054mm) TOP VIEW 17” (432mm) 10-3/16” (258mm) 20-1/4” 12” (514mm) (305mm) 33-7/16” 14-3/16” (848mm) (359mm) END VIEW SIDE VIEW * Shown with optional glass surround. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 6 PTO60 FINISHED TABLE TOP AND UNIT DIMENSIONS NOTE: PTO60 is two PTO30 units assembled end to end. 71-13/16" (1821mm) 71-13/16" 15" (1821mm) (432mm) 68-3/16" 12-13/16" (1731mm) (325mm) 68-5/16" 15" (1734mm) (381mm) * Shown with optional glass surround. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 7: Installation

    California to cause cancer, birth defects or other reproductive harm. THIS APPLIANCE SHALL BE USED ONLY OUTDOORS IN A WELL-VENTI- LATED SPACE AND SHALL NOT BE USED IN A BUILDING, GARAGE OR ANY OTHER ENCLOSED AREA. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 8: Installation Checklist

    At least 30% of the remaining wall area is open and unrestricted 30% or more in total of the remaining wall area is open and unrestricted. Open side at least 25% of total wall area Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 9: Minimum Clearances To Combustibles

    E: Alcove Width PTO30 84"(2134mm) Wall to Wall (Minimum) E: Alcove Width PTO60 100" (2540mm) Wall to Wall (Minimum) F: Alcove Depth 60" (1524mm) Front to Back Wall (Maximum) Notes: 0" No Hearth Required Alcove Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 10: Inner Framing Dimensions (Required)

    (ie. treated lumber, steel stud). 38-1/2”(978mm) TOP VIEW 1”(25mm) 38-1/2”(978mm) 15”(381mm) PTO30 SIDE VIEW END VIEW 68-1/2" (1740mm) 15" (381mm) TOP VIEW 10-1/2"" (267mm) 15" 68-1/2" (381mm) (1740mm) SIDE VIEW END VIEW PTO60 Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 11: Finishing

    Determine total thickness of top facing and adjust nailing brackets. Top facing material is to be brought to unit edge for fi nished look. Top = 1/2" thick material Middle = 3/4" thick material Bottom = 1" thick material Nailing bracket Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 12: High Elevation

    (clockwise) with a 1/8" fl at screwdriver. a soap and water solution or gas leak detector. Note: Screw should be snug, but do not over Do not use open fl ame for leak testing. tighten. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 13: Pto30 Wall Switch Installation

    Strain Relief 4) Route low voltage wire and battery extension wire through the strain relief. 5) Connect low voltage wire to supplied switch, fasten switch to right side of electrical box (polarity not important). Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 14: Pto60 Wall Switch Installation

    11) Place switch in OFF position until fi nal installation is complete. Note: Ensure the battery extension wires are approx. 8" in length inside the electrical box. This excess will ensure ease of battery replacement and servicing in the future. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 15: Drain Installation (Recommended)

    Cut notches into the top of the coupling reducer to prevent water pooling. Threaded Elbow Threaded @ 90° Reducer (PVC) (PVC) Reducer and elbow can be purchased from your local hardware store. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 16: Wiring Diagram

    The appliance, when installed, must be electrically grounded in accordance with local codes, or in the absence of local codes with the National Electrical Code, ANSI/NFPA 70, if applicable. PTO60 WIRING DIAGRAM ON/OFF Switch Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 17: Pto60 Assembly

    3) Bend fl ange 90º downward until it is fl at. 6) Install units together into framing. Secure in place with nailing strips. Do this on each burner only on end shown below. Bend fl ange till fl at Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 18: Pto30 Table Top Installation

    Note: Instructions below shown with the Plateau Series coffee table base. 1) Place table top over completed unit. Final Install 2) Place end caps over pilot and opposite end to complete installation. End Caps Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 19: Pto60 Table Top Installation

    Note: Unit shown below is not completed 3) Place end caps over both pilots at either end to complete installation. Note: 2 caps remain - these may be discarded or kept as spare parts. End Cap Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 20: Glass Crystal Installation On Burner

    For Units HZI390E, HZI390EB only Glass Crystals shown on Burner Optional Ceramic Spa Stones shown on burner. For units P33S, P33SE, L676S, U32S, U32SE, E33S only For units P33S,P33SE L676S, U32S, U32SE, E33S only Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 21: Volcanic Stone Installation On Burner

    Volcanic Stones Ivory /Tan + Glass Crystals For the PTO30, PTO60 For the HZO42 & HZO42AUS & Plateau Series only only Volcanic Stones Slate /Grey + Glass Crystals For the HZO42 & HZO42AUS only Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 22: Optional Log Set Installation

    Diagram 3 3) Install log E on the burner as shown below. Orient log E across log D in the same way and in a similar position as shown in Diagram 4. Diagram 4 Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 23 6) Install log C on the left side of the burner as shown below. Orient log C in the same way and in a similar position as shown in Diagram 7. Diagram 7 Final Install Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 24: Optional Glass Surround Installation

    Repeat process on other end. Press down fi rmly from to secure glass surround in position. Use care not to scratch surfaces. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 25: Operating Instructions

    OFF switch. c) Unit will repeat step 2. SHUTDOWN PROCEDURE 1) Turn ON/OFF switch. 2) If service is to be performed - you must discon- nect power to the unit, by removing the battery pack. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 26: Copy Of Lighting Plate Instructions

    After approximately 2 seconds turn on ON/OFF switch. a c c o m p a n y i n g c) L'unité répétera l'étape 2. THIS INSTRUCTION PLATE c) Unit will repeat step 2. appliance. 918-892a Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 27: Maintenance

    Failure to do this will result in burn stains on panels which you will be unable to remove. ® 5) The heater is fi nished in a heat resistant paint and should only be refi nished with heat resistant paint. Regency uses StoveBright Paint - Metallic Black #6309.
  • Page 28: Valve Assembly Replacement

    13) Rotate HI/LO modulationg valve all the way to the left for HI position. 8) Remove green EV2 wire connected to the gas valve. 14) Install new valve assembly and reverse steps 11-1. 15) Test gas connections for leaks. Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 29: Parts

    Burner Orifi ce #25 - NG 946-778 *Fire glass crystals (Colbalt Blue) 904-655 Burner Orifi ce #45 - LP * Glass crystals in 5lb bags - 2 required 376-028 Stainless steel weather cover 918-990 Manual Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 30 NOTES Regency Plateau™ PTO30 Outdoor Gas Fireplace...
  • Page 31: Warranty

    Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance Team carefully inspects each unit thoroughly ® before it leaves our facility. FPI Fireplace Products International Ltd. is pleased to extend this limited warranty to the original purchaser of a Regency Product. This warranty is not transferable.
  • Page 32 Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: ___________________________________________________________ Date Installed: ______________________________________________________ Serial No.: __________________________________________________________ Regency, Regency Plateau are trademarks of FPI Fireplace Products International Ltd. Printed in Canada © Copyright 2011, FPI Fireplace Products International Ltd. All rights reserved.

This manual is also suitable for:

Plateau pto30-lpPlateau pto60-ngPlateau pto60-lp

Table of Contents