Table of Contents
Advertisement
Table of Contents
I.
Pre-Installation........................................... 8
II.
Unpacking the Boiler ................................ 9
III.
Installation ................................................ 10
A. Venting ................................................ 10
B. Combustion Air ................................. 15
C. Water Treatment ................................ 17
D. Water Piping and Trim ...................... 18
E. Gas Piping ........................................... 21
F. Electrical ............................................. 24
G. Modular Systems ................................ 31
H. Condensate Drains ............................ 40
IV.
System Start-up ........................................ 41
V.
Lighting Instructions ............................... 44
VI.
Boiler Operational Sequence .................. 46
VII.
Service/Maintenance ............................... 48
Left Side
6"
Boiler Size
750/1000
1500
2000
3000
NOTES:
1.
When 3 or more units are mounted side-by-side, the front service clearance
increases by 12" and the rear service clearance increases by 24".
2.
Verify clearances with local codes.
3.
Net AHRI Ratings
A.
The Net AHRI Water Ratings shown are based on a piping and pickup allowance of 1.15.
B.
The manufacturer should be consulted before selecting a boiler for installations having unusual piping and
pickup requirements, such as intermittent system operation, extensive piping systems, etc.
C.
The ratings have been determined under the provisions governing forced draft boiler-burner units.
Minimum Clearance to Combustible Materials
Right Side
6"
Recommended Clearance for Service
Left Side
or
24"
24"
24"
24"
VIII.
IX.
X.
Front
Rear
24"
6"
Right Side
24"
24"
24"
24"
4
A. Safety and Operating Controls......... 49
B. Troubleshooting ................................. 50
C. Periodic Maintenance........................ 52
Repair Parts ............................................. 56
(TSBC™) ................................................... 85
A. Introduction ....................................... 85
B. Front Panel Display ........................... 86
C. Security Menu .................................... 88
D. Setup Menu ......................................... 89
E. Boiler Configuration Menu............... 92
F. System Configuration Menu ............. 93
G. Setpoints Menu .................................. 94
H. Communication Menu ..................... 95
I. Manual Mode Menu ........................... 96
Warranty ................................... Back Cover
Top
6"
Front and
Rear
24"
24"
24"
24"
24"
24"
36"
36"
Flue Connector
18"
Top
16"
19"
31"
26.5"
Hide quick links:
Advertisement
Table of Contents
