Fueling Instructions - Gasoline Vehicle - Club Car XRT 850 Owner's Manual

Fueling Instructions – Gasoline Vehicle
SAE 10W-30/ SAE 10W-40
SAE 5 W-30
213
Figure 33 Oil Viscosity Chart
9. Connect battery and spark plug wire. See Connecting the Battery – Gasoline Vehicles on page 12.
10. With the Forward/Reverse handle in the NEUTRAL position and the Maintenance/Service switch in the SERVICE
position, start and run the engine for a few minutes. Observe the drain plug from under the vehicle and watch for
oil leaks. If leaks appear, begin with step 1 and repeat the appropriate steps as needed to correct the problem.
11. Remove the dip stick and check the engine oil as a final step. Replace the dip stick.
FUELING INSTRUCTIONS – GASOLINE VEHICLE
See General Warnings on page 10.
DANGER
• Turn the key switch to the OFF position before fueling.
• Do not pour fuel into the fuel tank when the engine is hot or while it is running.
• Be sure the fuel tank ground wire on the tank is properly connected before fueling the vehicle.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be grounded. If
the pump is not grounded, the vehicle must be grounded to the pump before and during the fueling
operation.
• If the vehicle has an all-weather enclosure installed, be sure the fuel tank is properly vented as shown
(Figure 34).
• To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.
CAUTION
• Use unleaded gasoline only.
• Whenever possible, avoid using oxygenated and blended fuels.
• Do not use any fuel with an alcohol content that exceeds 10% by volume (such as E15 and E85).
Ethanol is an alcohol that readily absorbs moisture, causing corrosion of fuel system components. It
also damages neoprene and other plastic and rubber components. Use of these fuels in this vehicle
will void the warranty.
• Do not repeatedly attempt to start a vehicle when the fuel pump is dry (no gas in tank). Doing so
can damage the fuel pump.
Page 62 XRT 850 Electric and Gasoline Vehicle Owner's Manual
SAE 30